Club Car XRT 850 Owner's Manual page 40

Periodic Service Schedules
PERIODIC SERVICE SCHEDULE – ELECTRIC VEHICLES
REGULAR INTERVAL
Daily service by owner
Weekly service by owner
Monthly service by owner or trained
technician
Initial (one-time) inspection by owner or
trained technician after six weeks of use
Semiannual service by trained technician
only (or every 50 hours of operation,
whichever comes first)
Annual service by trained technician only
(or every 100 hours of operation, whichever
comes first)
Page 38 XRT 850 Electric and Gasoline Vehicle Owner's Manual
SERVICE
Pre-Operation and Daily Safety Checklist
Performance Inspection
Batteries
Batteries (For vehicles NOT equipped with the
Single-Point Watering System)
Batteries (For vehicles equipped with the
Single-Point Watering System). Water monthly
or according to the established watering
interval.
Batteries
Tires
General vehicle
Batteries (For vehicles newly equipped with
the SPWS)
Brake system
Electrical wiring and connections
Front wheel alignment and camber
Motor Controller Output Regulator (MCOR)
Batteries (For vehicles equipped with the
SPWS)
Batteries
Safety decals
See Pre-Operation and Daily Safety
Checklist on page 24.
See Performance Inspection on page 25.
Charge batteries (after each daily use only).
Check electrolyte level. Add water if
necessary. See Battery Care – Vehicles
Without the Single-Point Watering System
(SPWS) on page 45.
Water the batteries. Observe that water flow
occurs and no water overflows from any cell.
See Battery Care – Vehicles Equipped with
the Single-Point Watering System (SPWS)
on page 44.
Wash battery tops and clean terminals with
baking soda/water solution.
Check air pressure and adjust if necessary.
See Vehicle Specifications – Electric
Vehicles on page 64.
Wash battery compartment and underside of
vehicle.
For vehicles newly equipped with the SPWS,
manually check battery electrolyte levels of
all cells to verify correct valve operation. See
page 45.
Check brake shoes; replace if necessary or
adjust as required.
Check brake cables for damage; replace if
necessary.
Check brake cable equalizer adjustment;
adjust if necessary.
Check for tightness and damage.
Check and adjust as required. See Steering
and Front Suspension section in the
maintenance and service manual.
Check for loose hardware, cracks, or other
damage.
Manually check battery electrolyte levels of
all cells to verify correct valve operation. See
page 45.
If batteries are not performing as expected,
see the Batteries section in the maintenance
and service manual.
Check safety decals. Replace if damaged or
illegible.