Club Car XRT 850 Owner's Manual page 13

WARNING
• Follow the procedures exactly as stated in this manual, and heed all DANGER, WARNING, and
CAUTION statements in this manual as well as those on the vehicle and battery charger.
• Do not leave children unattended in vehicle at any time.
• Prior to leaving the vehicle unattended or servicing the vehicle, set the park brake, place the
Forward/Reverse handle or switch in the NEUTRAL position, turn the key switch to the OFF position,
and remove the key. Chock the wheels when servicing the vehicle.
• Improper use of the vehicle or failure to properly maintain it can result in decreased vehicle
performance, severe personal injury, or death.
• Any modification or change to the vehicle that affects the electrical system, stability or handling of
the vehicle, or increases maximum vehicle speed beyond factory specifications, can result in severe
personal injury or death.
• Do not operate the vehicle without an installed front bumper or brush guard that is specifically
designed and approved for use on this vehicle. Instability in the vehicle could cause serious injury or
death (Figure 6 and Figure 7).
• Check the vehicle for proper location of all vehicle safety and operation decals and make sure they are
in place and are easy to read.
• For vehicles with cargo beds, remove all cargo (including accessories) before servicing the vehicle.
Failure to heed this warning can result in severe personal injury or death.
• Only trained technicians should service or repair the vehicle or battery charger. Anyone doing even
simple repairs or service should have knowledge and experience in electrical and mechanical repair.
The appropriate instructions must be used when performing maintenance, service, or accessory
installation.
Electric vehicles only:
• Ensure battery connections are clean and properly tightened. See Battery Care – Vehicles Equipped
with the Single-Point Watering System (SPWS) on page 44 or Battery Care – Vehicles Without the
Single-Point Watering System (SPWS) on page 45.
• Place Tow/Run switch in the TOW position before disconnecting or connecting the batteries. Failure to
heed this warning can result in a battery explosion or severe personal injury.
• To avoid unintentionally starting an electric vehicle, disconnect the batteries and discharge the
controller. See Disconnecting the Batteries – Electric Vehicles on page 13.
Gasoline vehicles only:
• To avoid unintentionally starting a gasoline vehicle, disconnect the battery and spark plug wire. See
Disconnecting the Battery – Gasoline Vehicles on page 12.
• Frame ground – Do not allow tools or other metal objects to contact frame when disconnecting battery
cables or other electrical wiring. Do not allow a positive wire to touch the vehicle frame, engine, or
any other metal component.
All vehicles:
• Wear safety glasses or approved eye protection when servicing the vehicle or battery charger. Wear a
full face shield and rubber gloves when working on or near batteries.
• Do not wear loose clothing or jewelry such as rings, watches, chains, etc., when servicing the
vehicle or battery charger.
• Use insulated tools when working near batteries or electrical connections. Use extreme caution to
avoid shorting of components or wiring.
DISABLING THE VEHICLE
1. Engage park brake to lock wheels.
XRT 850 Electric and Gasoline Vehicle Owner's Manual
General Warnings
Page 11