1. Manuals
  2. Brands
  3. HearthStone Manuals
  4. Indoor Fireplace
  5. DVI 38
  6. Owner's manual

HearthStone DVI 38 Owner's Manual

Gas-fired direct-vent insert
Hide thumbs
Table of Contents

Advertisement

Quick Links

Download this manual
Read This Manual in Its Entirety
Operate And Maintain This Gas Heater According
To This Instruction Manual.
SAVE THESE INSTRUCTIONS!
WARNING: FOLLOW THE INFORMATION IN THESE
INSTRUCTIONS EXACTLY, IF NOT, A FIRE OR
EXPLOSION MAY
DAMAGE, PERSONAL INJURY OR LOSS OF LIFE.
WARNING: DO NOT STORE OR USE GASOLINE OR
ANY OTHER FLAMMABLE VAPORS AND LIQUIDS
NEAR THIS OR ANY OTHER GAS APPLIANCE.
WHAT TO DO IF YOU SMELL GAS:
Do not try to light any appliance.
Do not touch electrical switches; do not use the phone in
your building.
Immediately call your gas supplier from a phone outside
the structure. Follow your gas supplier's instructions.
If you cannot reach your gas supplier, call the fire
department or 911.
A qualified installer, service agency, or gas supplier must
perform installation and service of this appliance. In the
Commonwealth of Massachusetts, all installation of gas lines
and gas fittings must be performed by a licensed gas fitter or
licensed plumber.
RESULT
CAUSING PROPERTY
Owner's Manual
Operating Instructions
AVERTISSEMENT: ASSUREZ-VOUS DE BIEN SUIVRE
LES INSTRUCTIONS DONNÉ DANS CETTE NOTICE
POUR RÉDUIRE AU MINIMUM LE RISQUE D'INCENDIE
OU POUR ÉVITER TOUT DOMMAGE MATÉERIEL,
TOUTE BLESSURE OU LA MORT.
AVERTISSEMENT:
UTILISER D'ESSENCE NI D'AUTRE VAPERURS OU
LIQUIDES INFLAMMABLES DANS LE VOISINAGE DE
CET APPRAREIL OU DE TOUT AUTRE APPAREIL.
QUE FAIRE SI VOUS SENTEZ UNE ODEUR DE GAZ:
Ne pas tenter d'allumer d'appareil.
Ne touchez à aucun interrupteur. Ne pas vous servir des
téléphones se trouvant dans le batiment où vous vous
trouvez.
Appelez immédiatement votre fournisseur de gaz depuis un
voisin. Suivez les instructions du fournisseur.
Si vous ne pouvez rejoindre le fournisseur de gaz, appelez
le service dos incendies.
L'installation et service doit être exécuté par un qualifié installer,
agence de service ou le fournisseur de gaz.
Hearthstone Quality Home Heating Products, Inc. ®
DVI 38
(Model 8850)
GAS-FIRED
DIRECT-VENT INSERT
Installation
W/N 20535
NE
PAS
ENTRESPOSER
DVI-38 Model 8850
Manual: 6400-40472
R: 11/21/2012
&
.
NI

Advertisement

Table of Contents
loading

Related Manuals for HearthStone DVI 38

Summary of Contents for HearthStone DVI 38

  • Page 1 L’installation et service doit être exécuté par un qualifié installer, licensed plumber. agence de service ou le fournisseur de gaz. Hearthstone Quality Home Heating Products, Inc. ® DVI-38 Model 8850 Manual: 6400-40472 R: 11/21/2012...
  • Page 2 Intentionally Blank...
  • Page 3 Address: Phone: E-mail Website: Gas Supplier: Address: Phone: E-mail Website: Read this Owner’s Manual before installing, or operating your DVI 38. Retain this manual for future reference. SERVICE RECORD Date Who Performed Work Work Performed Notes: WHAT WHEN Firebox Cleaning.....

  • Page 4: Table Of Contents

    ................................5 NTRODUCTION & G ............................6 AFETY RACTICES ................................. 9 PECIFICATIONS DVI 38 8850 Model Overview ........................... 11 Control Functions ..............................13 ............................ 15 NSTALLATION REPARATION Codes ..................................15 Items Required for Installation ..........................15 Packing List ................................15 Unpacking and Inspection ............................

  • Page 5: Introduction

    Firebox Accent Light controlled by the ease of use, clean, and efficient heat for years to remote. come. The DVI 38’s copious glass, sleek styling, and 2. The option to toggle back and forth between an enameled or painted façade options gives the DVI Intermittent (IPI) or Continuous (CPI) pilot mode.

  • Page 6: Safety & Good Practices

    Safety & Good Practices Your DVI 38 is an attractive and extremely efficient Service Caution and easy to use heater, utilizing today’s best If you believe your DVI 38 is not in any way technologies. By following a few simple safety performing properly,...
  • Page 7 “Clearances To Combustibles” If the decorative ceramic log, or burner material section of this manual. supplied with the DVI 38 are damaged or parts are missing, they must be replaced with the same, or DUE TO HIGH TEMPERATURES THE APPLIANCE approved Hearthstone replacement parts.
  • Page 8 Hearthstone Quality Home Heating Products, Inc. DVI-38 Model 8850 Mobile Home Installations (Cet appareil peut être installé dans un maison préfabriquée (mobile) déjá installée á demeure si les This appliance may be installed in an aftermarket réglements locaux le permettent.

  • Page 9: Specifications

    DVI-38 Model 8850 Specifications : Gas-Fired Direct-Vent Fireplace Heater Certified for use by: ISTED Model: DVI 38 Direct-Vent Gas Fireplace Board of State Examiners of Plumbers & Gasfitters Insert (8850) 100 Cambridge Street, Room 1511 Testing Agency: Intertek Testing Services Boston, MA 02202 NA, Inc.
  • Page 10 Hearthstone Quality Home Heating Products, Inc. DVI-38 Model 8850 Figure 2 – 8850 Minimum Fireplace Dimensions Specification INPUT RATING (Btu/hr) (0-610 m) 38,000 38,000 MAXIMUM OUTPUT (Btu/hr) (0-610 m) 25,422 24,814 MINIMUM INPUT (Btu/hr) (0-610m) 17,000 16,000 HIGH ALTITUDE RATING (Btu/hr) 610-1370 m...

  • Page 11: Dvi 38 8850 Model Overview

    DVI 38 8850 Model Overview Proflame GTMFS System The Proflame GTMFS is a modular remote control system that directs the functions of the DVI 38. The Proflame GTMFS System is configured to control the on/off, main/split burner operation, its flame levels, and provides Manual and Smart thermostatic control of the hearth appliance.
  • Page 12 Hearthstone Quality Home Heating Products, Inc. DVI-38 Model 8850 be plugged directly into a properly grounded three- the remote. In the Smart thermostatic mode, as the prong receptacle. Do not cut or remove the grounding room temperature approaches the limit set for shut down the valve will automatically gradually step down prong from the plug.

  • Page 13: Control Functions

    Pilot Mode Continuous Pilot (CPI): Running the DVI 38 in CPI mode will keep your pilot on even when the thermostat does not call for heat and when the burner is not lit. This is an advantage in cooler temperatures or under windy conditions.
  • Page 14 Hearthstone Quality Home Heating Products, Inc. DVI-38 Model 8850 Remote Transmitter Figure 9 - Remote Transmitter Function Keys (remote color may differ from shown) ON/OFF Key: Controls the insert. Mode Key: Toggles through the component to be controlled (split flow burner, blower or auxiliary...

  • Page 15: Installation Preparation

    INSPECTOR L’APPAREIL ET REMPLACER TOUTE Remove the shrink-wrap and all other packaging PARTIE DU SYSTÈME DE CONTRÔLE ET TOUTE materials taking care not to damage the stove’s COMMANDE QUI ONT ÉTÉ PLONGÉS DANS finish. Inspect the DVI 38 for visible or concealed L’LAU)
  • Page 16 Hearthstone Quality Home Heating Products, Inc. DVI-38 Model 8850 damage. The unit should be square and true. Any sheet metal parts should be smooth and free of bends and dents. If visible or concealed damage is found suspected, contact your dealer instructions.
  • Page 17 Hearthstone Quality Home Heating Products, Inc. DVI-38 Model 8850 Firebox Access 1. If installed, remove the Façade. 2. Remove the front screen by lifting it up and off the glass frame – pulling it from behind the lower glass retainer. Remove all packaging material from the screen (if applicable).

  • Page 18: Clearances To Combustibles

    Figure 18 - Mantle Clearances Protection Ensure the masonry fireplace and flue complies The DVI 38 requires a non-combustible hearth, or with the applicable codes and both are clean and in hearth pad that extends no less than 16” in front of good condition.
  • Page 19 Trim panels and surrounds shall not seal ventilation openings in the fireplace. The minimum size Exhaust fireplace the DVI 38 insert will fit into is 33” W x 22- 1/4” H x 16” D. Intake Installation of the Co-linear Vent Pipe Mark each end of one of the flexible vent pipes “intake”...
  • Page 20 Hearthstone Quality Home Heating Products, Inc. DVI-38 Model 8850 Exhaust Gasket Material Intake Installation Tool Retaining Tracks for the Flue Vent Plate Figure 20 – Flue Plate & Installation Tool Detail 1. Carefully slide the insert into place while pulling 2.

  • Page 21: Venting Information

    See page 22. Venting Terminations The maximum vertical run is 35’ The DVI 38 cannot be vented jointly with any other The minimum vertical run is 10’ (NG) solid fuel or gas appliance. It must be vented The minimum vertical run is 16’ (LP) When vertically directly to the outside of the building using installed with a partial intake system.
  • Page 22 Hearthstone Quality Home Heating Products, Inc. DVI-38 Model 8850 The DVI 38 8850 is approved for use with direct vent chimney conversion kits in masonry or prefabricated solid fuel listed chimneys. The following installation requirements must be followed: In a masonry chimney, a fireclay liner or listed steel liner, must be present the entire length of the chimney.
  • Page 23 Hearthstone Quality Home Heating Products, Inc. DVI-38 Model 8850 Figure 22 – Partial Co-axial Venting Installation Components...
  • Page 24 Hearthstone Quality Home Heating Products, Inc. DVI-38 Model 8850 Figure 23 – Full Co-axial Venting Termination Diagram...

  • Page 25: Electrical System Information

    (ATTENTION: AU MOMENT DE L’ENTRETIEN DES COMMANDES, ÉTIQUETEZ TOUS LES FILS AVANT LE DÉBRANCHEMENT. DES ERREURS DE CÂBLAGE PEUVENT ENTRAÎUN FONCTIONNEMENT INADEQUATE ET DANGEREUX.) The proper location of wire connections is shown in the following figure. Figure 24 - DVI 38 8850 Wiring Diagram...

  • Page 26: Gas Supply & Connections

    WITH THE MOST CURRENT EDITION OF THE NATIONAL FUEL GAS CODE ANSI Z223.1 (NFPA 54) OR CAN/CGA B149 INSTALLATION CODE. NFPA Code and Hearthstone require the use of a dedicated sediment trap just upstream of the unit. Damage to the valve, or other components due to the lack of a sediment trap are not covered by warranty (see figure 26).

  • Page 27: Gas Connections

    ½ psig. The DVI 38 must be isolated from the gas supply piping system by closing its individual manual shutoff valve during any pressure testing of the gas supply piping system at test pressures equal to or greater than ½...

  • Page 28: Baffle, Log Set, & Screen Placement

    Hearthstone Quality Home Heating Products, Inc. DVI-38 Model 8850 Baffle, Log Set, & Screen Placement CAUTION: FRAGILE! HANDLE LOG SET WITH 4. Next, install the left baffle panel against the left CARE. ALWAYS WEAR GLOVES AND SAFETY firebox side. To allow the left panel to clear the GOGGLES WHILE HANDLING THE LOG SET.

  • Page 29: Installation Of The Log Set

    Hearthstone Quality Home Heating Products, Inc. DVI-38 Model 8850 4. Place log 3 as shown. Installation of the Log Set (Refer to the following images in this section for log set assembly) 1. Remove the packaging material around the log set assembly.

  • Page 30: Completing The Installation

    Hearthstone Quality Home Heating Products, Inc. DVI-38 Model 8850 To remove the log set, follow the Installation of Log Completing the Installation Set instructions in the reverse order (see page 28). 1. Close the firebox – reverse the firebox access procedure outlined on page 17.

  • Page 31: Surround Installation

    5. If properly installed, the façade should slide from center to the right with ease. Only operate the DVI 38 with the façade in the center position. 6. To remove the façade simply slide the façade to the right and lift up and away from the insert.

  • Page 32: Lighting & Operation

    PERFORMED QUALIFIED SERVICE PERSONNEL. When lit for the first time, the DVI 38 will emit some smoke and fumes. This is normal “off-gassing” of Lighting Instructions the paints and oils used in the manufacturing and assembly of the unit. Open windows to vent the When lighting for the first time, use a gas sniffer room if necessary.
  • Page 33 Hearthstone Quality Home Heating Products, Inc. DVI-38 Model 8850 is too small or misdirected away from the flame the gas supply pressure or with changes to the sensor. venting configuration. Qualified service personnel must perform supply line/manifold gas line pressure adjustments.

  • Page 34: Daily Operation

    Note: Very little movement is needed to Daily Operation substantially change burn flame Your DVI 38 gas-fired heater is easily operated once patterns. Some conditions cannot be corrected properly installed and adjusted by qualified service through air shutter adjustment; an adjustment personnel.
  • Page 35 Hearthstone Quality Home Heating Products, Inc. DVI-38 Model 8850 on the inside of the window glass. This is normal, To Turn off Gas and Shut Down the and the condensation will evaporate within the first Appliance: few minutes of operation. If you notice continuous 1.

  • Page 36: Routine Maintenance And Care

    Hearthstone Quality Home Heating Products, Inc. DVI-38 Model 8850 Routine Maintenance and Care Your DVI 38 requires minimal routine maintenance Annually: and care. Ensure the unit is cool and off when cleaning, or servicing. Clean Firebox, Blower, Pilot, & Burner WARNING: DO NOT SUBSTITUTE MATERIALS.
  • Page 37 Hearthstone Quality Home Heating Products, Inc. DVI-38 Model 8850 proper operation. Flame patterns should look similar to the flames on page 34. Regularly check to ensure Baffle Shelf the area around the DVI 38 is kept free from combustible materials, gasoline, other flammable vapors and liquids.

  • Page 38: As Needed

    If the vent-air exhaust/intake system is disassembled Hearthstone Dealer. for cleaning, or any reason, reinstall per the 1. Allow the DVI 38 to cool completely. Dismount instructions provided in this manual, or by the the front façade. specific venting manufacturer.

  • Page 39: Replacement Parts & Accessories List

    PARTS OR SERVICE, CONTACT YOUR AUTHORIZED HEARTHSTONE RETAILER. For the name of the authorized retailer nearest to you, visit our website www.hearthstonestoves.com or write: Hearthstone Quality Home Heating Products, Inc. E-mail: inquiry@hearthstonestoves.com 317 Stafford Ave. Morrisville, Vermont 05661-8695 DVI 38 Model 8850 Gas Burning Fireplace Insert...

  • Page 40: Troubleshooting

    Hearthstone Quality Home Heating Products, Inc. DVI-38 Model 8850 Troubleshooting Symptom Possible Cause Corrective Action 1. Pilot will not light. A. Power supply not plugged in A. Ensure power supply is plugged in and receiving 120V and/or batteries are dead.
  • Page 41 Hearthstone Quality Home Heating Products, Inc. DVI-38 Model 8850 Symptom Possible Cause Corrective Action 5. Frequent pilot outage A. Pilot flame may be too low or A. Clean and/or adjust the pilot flame for maximum problem in CPI mode. blowing, (high), causing the pilot impingement on the rectification sensor.

  • Page 42: Rating Label

    Hearthstone Quality Home Heating Products, Inc. DVI-38 Model 8850 Rating Label W/N 20535...
  • Page 43 Warranty Registration Form, which is enclosed in the Owner’s Information Packet, to the following address: Hearthstone Quality Home Heating Products, Inc. Warranty Department 317 Stafford Avenue Morrisville, VT 05661 NOTE: SENDING IN THE SIGNED WARRANTY REGISTRATION FORM IS NOT REQUIRED AS A CONDITION OF WARRANTY COVERAGE OR HEARTHSTONE’S PERFORMANCE.

This manual is also suitable for:

8850

Table of Contents