Exmark Lazer Z Operator's Manual page 39

For Exmark Mower Parts Call 606-678-9623 or 606-561-4983
5.1.18
5.1.19
5.1.20
5.1.21
5.1.22
5.1.23
5.1.24
Lubricate seat switch actuator: (All units except for Kohler 26 HP EFI)
Service Interval: 160 hrs.
a) Stop engine, wait for all moving parts to stop, and remove key.
b) Tilt seat up.
c) Lubricate switch actuator rod with spray type lubricant or light oil.
Lubricate brake handle pivot:
Service Interval: 160 hrs.
a) Stop engine, wait for all moving parts to stop, and remove key.
b) Lubricate bronze bushings on brake handle pivot with a spray type lubricant
or light oil.
Lubricate brake rod bushings:
Service Interval: 160 hrs.
a) Stop engine, wait for all moving parts to stop, and remove key.
b) Tilt seat up.
c) Lubricate bronze bushings on each end of brake rod shaft with a spray type
lubricant or a light oil (bushings are located to the inside of the flange bearings).
Lubricate motion control bronze bushings:
Service Interval: 160 hrs.
a) Stop engine, wait for all moving parts to stop, and remove key.
b) Tilt seat up.
c) Lubricate bronze bushings on flange bearings securing the motion control
arm shafts with a light oil or a spray type lubricant.
Remove engine shrouds and clean cooling fins (Air-cooled units only):
Service Interval: 80 hrs.
a) Stop engine, wait for all moving parts to stop, and remove key.
b) Remove cooling shroud clean-out covers (Kohler) or cooling shrouds
(Kawasaki air-cooled) from engine and clean cooling fins. Also clean dust, dirt,
and oil from external surfaces of engine, which can cause improper cooling.
c) Make sure cooling shroud clean-out covers or cooling shrouds are reinstalled.
Operating the engine without cooling shroud clean-out covers or cooling
shrouds will cause engine damage due to overheating.
Check spark plugs:
Service Interval: 160 hrs.
a) Remove spark plugs, check condition and reset gaps, or replace with new
plugs. See Engine Owners Manual.
Change fuel filter:
Service Interval: As Required
a) A fuel filter is installed between the fuel tanks and the engine. Replace
when necessary.
www.mymowerparts.com
- 34 -