Subscribe to Our Youtube Channel
Related Manuals for Winco CSAW6010DEX/C
Summary of Contents for Winco CSAW6010DEX/C
- Page 1 INSTALLATION, OPERATION, and MAINTENANCE INSTRUCTIONS CSAW6010DEX/C OWNERS MANUAL 60706-177...
-
Page 2: Table Of Contents
PROPER USE AND INSTALLATION USING THIS MANUAL Congratulations on your choice of a Winco generator set. You must be sure your new engine generator set is: * Properly serviced before starting You have selected a high-quality, precision-engineered... -
Page 3: Guide To Product Safety
This engine generator set has been designed and manufac- b. Keep fuel containers out of reach of children. tured to allow safe, reliable performance. Poor maintenance, c. Do not smoke or use open flame near the generator set improper or careless use can result in potential deadly or fuel tank. -
Page 4: Specification Table
SPECIFICATIONS RESTRICTED USES 1. DO NOT remove from the base assembly. Removal of MODEL CSAW6010DEX/C the generator from the base assembly or operating without the shock mounts installed may cause excessive Generator vibration and damage to the engine generator set. -
Page 5: Unpacking The Unit
Starting Electric Motors - Electric motors require much Trying to start a larger motor or higher code (ie. J or K) motor more current (amps) to start them than to run them. may result in damage to both the generator and the electric Some motors, particularly low cost split-phase motors, motor especially 120 volt motors. -
Page 6: Operation/Installation
1. Lubrication - Before starting the engine, fill the away from the battery. Ventilate the area when charging or crankcase to the proper level with a good quality oil. The using the battery in an enclosed space. Lead acid recommended grade of oil and quantity of oil required is batteries contain sulfuric acid, which causes severe burns. -
Page 7: Starting Hints
2. Electric Starting - Always keep the battery charged, but CAUTION: EQUIPMENT DAMAGE especially during cold weather operation. The output voltage should be checked to insure the a. Turn on the fuel supply and prime the fuel line up to generator is working properly prior to connecting a load to the injector pump. -
Page 8: Connecting The Load
WIRING voltmeter, it can be checked with a portable meter. Frequency can be checked by using an electric clock with a sweep second hand. Timed against a wrist watch or a Plug your tools such as drills, saws, blowers, sump pump stop watch the clock should be correct within +/- 2 and other items to be powered directly into the generator seconds. -
Page 9: Engine Care
(ET/S) system available through your WINCO dealer. 3. Servicing Air Cleaners: Consult engine operators The emergency distribution panel must be installed manual for recommendations, procedures and intervals. by a licensed electrician according to all applicable Service more often if necessary if very dirty. Replace the codes. -
Page 10: Cleaning
CLEANING —————————————————————————-- PROBLEM (SYMPTOMS) POSSIBLE CAUSES —————————————————————————— Remove dirt and debris with a cloth or brush. DO NOT use Won’t Start (electric) *Fouled fuel injector. high pressure spray to clean either the engine or the *Out of fuel. generator. This high pressure spray could contaminate *Dead battery. -
Page 11: Ac Wiring Diagram
5335-000 Page 9 60706-177... -
Page 12: Month Warranty
To the extent permitted by law, any and all warranties, including those of merchantability and fitness for a particular purpose, are limited to 24 months from date of purchase. In no event is WINCO liable for incidental or consequential damages.
Need help?
Do you have a question about the CSAW6010DEX/C and is the answer not in the manual?
Questions and answers