3000 PSI / 2.5 GPM PRESSURE WASHER MODEL NUMBER 76520 10006 Santa Fe Springs Road SAVE THESE INSTRUCTIONS Santa Fe Springs CA 90670 Important Safety Instructions USA / 1-877-338-0999 MADE IN CHINA are included in this manual. REV 76520-20120824 www.championpowerequipment.com...
Page 2
Have questions or need assistance? Do not return this product to the store! WE ARE HERE TO HELP! Visit our website: www.championpowerequipment.com for more info: • Product Info & Updates • Tech Bulletins • Frequently Asked Questions • Product Registration –...
Introduction Accessories Congratulations on your purchase of a Champion Power Champion Power Equipment manufactures and sells Equipment pressure washer . CPE designs and builds accessories designed to help you get the most from pressure washers to strict specifications . With proper your purchase .
. Please call our help line at situation which, if not avoided, could result in 1-877-338-0999 death or serious injury . CAUTION CAUTION indicates a potentially hazardous situation which, if not avoided, may result in minor or moderate injury . REV 76520-20120824...
• DO NOT remove fuel tank cap or fill fuel tank while engine is hot or running (allow engine to cool two minutes before refueling) . Always fill the tank slowly . • Never disconnect the high pressure discharge hose from the machine while the system is pressurized . REV 76520-20120824...
Page 7
. – Equipment sparks, smokes or emits flames – Equipment vibrates excessively CAUTION NEVER run the unit dry . Be sure the water supply is completely turned on before operating the unit . REV 76520-20120824...
(12) High Pressure Hose Connection off to engine . Recoil Starter – Used to manually start the engine . (13) 12” Never Flat Tires Choke (14) High Pressure Hose Hanger – Used to hold high pressure hose when not in use . REV 76520-20120824...
The engine is equipped with a low oil shut-off and will stop when the oil level in the crankcase falls below the threshold level . NOTE Check oil often during the break-in period . Refer to the Maintenance section for recommended service intervals . REV 76520-20120824...
It is advisable to always shut off the fuel supply, result in blow back of fuel at the operator while run the engine to fuel starvation and drain the tank filling . when the equipment is not in use for more than 30 days . REV 76520-20120824...
Take the end of the High Pressure hose that isn’t connected to the gun inlet and insert it into the connection on the pump . Rotate hose end (clock wise) until secure . Tighten connection . DO NOT OVER TIGHTEN . REV 76520-20120824...
6 . Pull the starter cord slowly until resistance is felt and then pull rapidly . SEE NOTE. 7 . As engine warms up, move the choke lever (Item D) to “Run” and adjust the throttle as needed . REV 76520-20120824...
. Begin high pressure rinsing at the bottom and work your way upward . On particularly tough stains, use a brush in combination with detergents and high pressure rinsing . REV 76520-20120824...
Storage section for 6 . Re-engage the trigger safety latch . proper engine and fuel storage . 7 . Before overnight storage, long term storage, or transporting unit, disconnect the water supply and turn off the fuel supply valve . REV 76520-20120824...
. To alleviate high altitude issues other than the natural power loss, Champion Power Equipment can provide a high altitude carburetor main jet . The alternative main jet and installation instructions can be obtained by contacting Customer Support .
If using the dipstick to check oil level, DO NOT screw 8 . Reassemble the two elements and reattach . in the dipstick while checking . 9 . Reattach the air fi lter cover and tighten wing nuts . DO NOT OVER TIGHTEN . REV 76520-20120824...
(paper clip) to loosen up any particles in Contact our help line at 1-877-338-0999 to locate the the quick connect nozzle and flush with water . nearest Champion Power Equipment certified service dealer for your maintenance needs . Every 8 hours or daily...
It is advisable to always shut off the fuel supply, run the comes out of the pump outlet . engine to fuel starvation and drain the tank when the equipment is not in use for more than 30 days . REV 76520-20120824...
10% by volume . Use 10W-30 automotive oil . Oil capacity is up to 0 .63 qt . (0 .6 L) . Please reference the following chart for recommended oil types for use in the pressure washer . REV 76520-20120824...
Pump will build pressure with each pull . Pull gun trigger after 2 pulls of recoil, to release pump pressure . for further technical support: Technical Service Mon – Fri 8:30 AM – 5:00 PM (PST/PDT) Toll Free: 1-877-338-0999 tech@championpowerequipment .com REV 76520-20120824...
– Cosmetic defects such as paint, decals, etc . Warranty Qualifications – Wear items such as filter elements, o-rings, etc . Champion Power Equipment (CPE) will register this – Accessory parts such as starting batteries, and warranty upon receipt of your Warranty Registration Card and a copy of your sales receipt from one of CPE’s retail...
Page 27
The California Air Resources Board (CARB) and the United States Environment Protection Agency (U.S. EPA.) Emission Control System Warranty Your Champion Power Equipment (CPE) engine complies with both the U.S. EPA and state of California Air Resources Board (CARB) emission regulations.
Page 28
EMISSION CONTROL SYSTEM WARRANTY The following are specific provisions relative to your Emission Control System Warranty Coverage. 1. APPLICABILITY: This warranty shall apply to 1995 and later model year California small off-road engines (for other states, 1997 and later model year engines). The ECS Warranty Period shall begin on the date the new engine or equipment is delivered to its original, end-use purchaser, and shall continue for 24 consecutive months thereafter.
Page 29
You must take your CPE engine or the product on which it is installed, along with your warranty registration card or other proof of original purchase date, at your expense, to any Champion Power Equipment dealer who is authorized by Champion Power Equipment, Inc. to sell and service that CPE product during his normal business hours.