Table of Contents
Advertisement
Quick Links
Advertisement
Table of Contents
Subscribe to Our Youtube Channel
Related Manuals for Precor CW-113
Summary of Contents for Precor CW-113
- Page 1 Assembly Guide CW-113...
-
Page 3: Important Safety Instructions
You can find the serial number printed on a label you skip ahead, you may learn later that you have affixed to the CW-113. For future reference, write the to disassemble components and that you may serial number in the space provided below. -
Page 4: Table Of Contents
CW-113 Assembly and Maintenance Guide Table of Contents Important Safety Instructions ....................3 Obtaining Service ........................3 Preparations ....................5 Unpacking the Equipment ....................... 5 Required Tools ......................... 5 Installation Requirements ......................5 Hardware Kit ..........................6 Assembly Instructions .................. 7 Open the Box .......................... -
Page 5: Preparations
⁄ -inch Allen wrench • Install components in the sequence shown. The CW-113 parts are inspected before shipment. • Insert all fasteners in the same direction. For Each unit contains several pieces that require aesthetic purposes, insert all the fasteners in the assembly. -
Page 6: Hardware Kit
CW-113 Assembly and Maintenance Guide Hardware Kit Fastener Fastener ³⁄₈ x ¾-inch Buttonhead screw (A) ½-inch Washer (F) ³⁄₈-inch Split washer (B) ½-inch Lock nut (G) ³⁄₈ x 2¾-inch Buttonhead screw (C) ⁵⁄₁₆ x 3-inch Buttonhead screw (H) ³⁄₈-inch Washer (D) ⁵⁄₁₆-inch Split washer (J) -
Page 7: Assembly Instructions
CW-113 Assembly and Maintenance Guide Assembly Instructions Handlebar Assembly of the CW-113 takes about 50 minutes to complete. If this is the first time you have assembled Roller Pads this type of equipment, plan on allowing more time. Thigh Pad Be careful to open boxes and assemble components in the sequence presented in thie manual. -
Page 8: Assemble The Unit
CW-113 Assembly and Maintenance Guide Assemble the Unit 1. Attach the Main Frame to the Stabilizer using 4 - ¾" buttonhead screws 4 - split washers four ¾-inch buttonhead screws (A) four ³⁄₈-inch split washers (B) Spring Cushion Wrench tighten. - Page 9 CW-113 Assembly and Maintenance Guide 5. Pull on the Adjustment Pin and slide the Back Adjustment through the Main Frame. Release the Adjustment Pin while it is aligned with the Back Adjustment middle hole. Note: Make sure the Springs slide onto the posts...
- Page 10 CW-113 Assembly and Maintenance Guide 8. Slide the Roller Bar through Holder Assembly, and then place a Round Cap onto each end of the Roller Bar. Slide the Round Caps against the Holder Assembly. 9. Slide a Roller Pad onto each end of the Roller Bar, followed by a Roller Cap.
-
Page 11: Assemble The Pads
1¼-inch buttonhead screws (L) ⁄ -inch split washers (J) ⁄ -inch washers (K) Wrench tighten. This completes the assembly of the CW-113. 4 - 3" buttonhead screws 4 - split washers 4 - washers 6 - 1¼" buttonhead screws 6 - split washers... -
Page 12: Clean The Pads And Assembly
Frequently vacuum the floor underneath the CW-113 to prevent the accumulation of dust and dirt. If necessary, use the Back Support to lift the front end and tip the CW-113 onto its wheels to roll it to a different location. Clean the Pads and Assembly page 12... -
Page 13: Limited Warranty Statement
Five Years: Rotary Bearings, Weight Stacks, Pulleys, Guide Rods, Structural Moving buyer, or if the warranty repairs did not remedy the defect and the buyer notifies PRECOR or its Parts authorized dealer or sales representative of the failure of the repairs within sixty (60) days after they... - Page 14 CW-113 Assembly and Maintenance Guide Notes: page 14...
-
Page 16: Specifications
Precor is widely recognized for its innovative, award winning designs of exercise equipment. Precor aggressively seeks U.S. and foreign patents for CW-113 Assembly & Maintenance Guide CW33616-101 both the mechanical construction and the visual aspects of its product design. Any party contemplating the use of Precor’s product designs is hereby Warranty Statement CW31973-102 forewarned that Precor considers the unauthorized appropriation of its proprietary rights to be a very serious matter.
Need help?
Do you have a question about the CW-113 and is the answer not in the manual?
Questions and answers