Table of Contents
Advertisement
MAINTENANCE
Tires
Since your tires are flat free tires, there is no need to ever worry about tire air pressure.
General Maintenance and Lubrication
• Inspection for loose bolts, and tightening bolts is recommended on a regular basis.
• Most lubricated components on the EZ Chopper Portable scooter are designed to be
maintenance free and are sealed. Therefore lubrication is not required for these
components. However, the rear axles should always have a very light coat of multipurpose
grease.
DO NOT USE TOO MUCH GREASE!
Drips may stain or damage carpets, furnishings, etc.
• It is recommended that the rear axles be checked and cleaned occasionally for hair and
debris build-up, which will hinder the performance of the unit.
• Check the batteries on a regular basis. For extended battery life, it is highly
recommended that the batteries be fully charged after each use. If the batteries are weak,
severely discharged or old, a variety of problems may occur with the unit including charging
problems, reduced speed, loss of range, and others. Please contact Shoprider® for battery
replacement.
TROUBLESHOOTING GUIDE
Circuit Breaker
Your scooter is fitted with the latest in electronic controls that are programmed to protect
the electrical system from abnormal overloads. Provided for extra protection is a circuit
breaker, located on the side of the battery pack. Should there be a situation where your
scooter stops for no apparent reason, please check that the circuit breaker has not popped.
Check List
If your scooter fails to operate, please check the following:
• Unit is switched on.
• Battery pack is seated correctly and making good contact.
• Battery level shows full charge.
• Reset circuit breaker.
• Hand brake locking mechanism is unlocked.
Please consult SHOPRIDER if your scooter does not run after checking these points.
5/18/2007
14
Advertisement
Table of Contents
