Maintenance; Troubleshooting Guide - Shoprider GK4 User Manual

MAINTENANCE

Tyres
Since your tires are flat free tyres, there is no need to ever worry about tyre air pressure.
General Maintenance and Lubrication
Inspection for loose wheel bolts, seat and arm tightening bolts, and other nuts and bolts is
recommended on a regular basis.
Most lubricated components on the GK4/GK7-3/GK9 Portable Scooter are designed to be
maintenance free and are sealed.
components. However, the driving axles and seat post should always have a very light coat
of multipurpose grease.
DO NOT USE TOO MUCH GREASE!
Drips may stain or damage carpets, furnishings, etc.
It is recommended that the driving axles (inside the drive wheel assembly) be checked and
cleaned occasionally for hair and debris build-up, which will hinder the performance of the
unit.
Check the batteries on a regular basis. For extended battery life, it is highly recommended
that the batteries be fully charged after each use. If the batteries are weak, severely
discharged, or old, a variety of problems may occur with the unit including charging problems,
reduced speed, loss of range, and others. Please contact your local Shoprider® provider for
battery replacement.

TROUBLESHOOTING GUIDE

Circuit Breaker (Reset Button)
Your scooter is fitted with the latest in electronic controls that are programmed to protect
the electrical system from abnormal overloads. Provided for extra protection is a circuit
breaker, located on the side of the battery pack. Should there be a situation where your
scooter stops for no apparent reason, please check that the circuit breaker has not popped.
NOTE: To preserve battery charge, your scooter may go into sleep mode after being idle for
a few minutes. To remove from sleep mode, turn the key off and back on again.
Check List
If your scooter fails to operate, please check the following:
Unit is switched on.
-
Drive/Freewheel mechanism is in the drive position.
-
All plugs and connectors are clean and firmly connected.
-
Battery level shows full charge.
-
If the free wheel device has been operated with the scooter switched on, then the scooter
will not operate until the ignition key has been switched off and then on again.
Therefore, lubrication is not required for these
15