Boss Hoss Cycles Year 2005 Owner's Manual page 70

OIL USED: Mobil 1 – MX4T Synthetic Oil
FILTER: This is an internal filter that is removed, cleaned, and reinstalled. It is
located inside of the transmission just above the bottom plate.
SERVICING OF FILTER: Clean filter at 500 miles, 2500 miles and every 10,000
miles as directed. With the transmission warm, remove one (1)of the button head bolts
from the bottom of transmission to allow the fluid to drain. After the fluid has drained,
remove the second button head bolt and remove the pan bottom to expose the
transmission filter. Remove filter and clean with solvent. Blow particles, sludge, etc.
from filter and replace the filter to its original position. Replace pan bottom, resealing or
replacing the gasket and fill transmission housing with 2 QTS. MOBIL 1 – MX4T oil or
to the proper level. (CAUTION: DO NOT OVERFILL). The filler plug is located on the
right side, front corner of the transmission just below the fuse panel.
CAUTION
Pan bolt torque is 4 ft/lbs. Bolt over-torque could result in bolt failure and/or flexing
of transmission pan resulting in leaking.
NOTE
This service will drain oil in transmission only. The converter will hold
approximately 2.5 quarts that cannot be drained without removal. The transmission
housing should hold approximately 2 quarts.
© Copyright Boss Hoss Cycles, Inc. 2004. All Rights Reserved.
64