Limited Warranty - Champion MARQUIS 3000 DD Owner's Manual

• Oil bearings. The blower bearings and cooler motor in this
unit should be oiled with a few drops of non-detergent 20/30
weight oil once each year. The motor does not need oil if it has
no oil lines for oiling. Motors that have no lines are lifetime
oiled at the factory and require no further oiling for the life of
the unit.
CAUTION:
Do not over oil. Over oiling can cause motor
burn out, due to excessive oil getting into motor winding.
• Change Pads. The pads should be replaced once or twice a
season, depending upon the length of the season. At the be-
ginning and at mid season a clean pad is more absorbent and
efficient and will deliver substantially more
cool air.
• Check belt tension. A 3 lb. force
should deflect the belt 3/4 inches
(see Fig. 13). Readjust belt if
needed.
• Check bleed-off valve to be sure it is not clogged.
This warranty is extended to the original purchaser of an evaporative cooler installed and used under normal conditions. It
does not cover damages incurred through accident, neglect, or abuse by the owner. We do not authorize any person or
representative to assume for us any other or different liability in connection with this product.
Terms And Conditions Of The Warranty
For Eight Years from date of installation, we will replace the original base assembly if water leakage should occur due to rust
out.
For One Year from date of installation, we will replace any original component provided by Champion Cooler which fails due to any
defect in material or factory workmanship only.
Exclusions From The Warranty
We are not responsible for replacement of cooler pads. These are disposable components and should be replaced periodi-
cally. We are not responsible for any incidental or consequential damage resulting from any malfunction.
We are not responsible for any damage received from the use of water softeners, chemicals, descale material, plastic wrap,
or if a motor of a higher horsepower than what is shown on the serial plate is used in the unit.
We are not responsible for the cost of service calls to diagnose cause of trouble, or labor charge to repair and/or replace parts.
How To Obtain Service Under This Warranty
Contact the Dealer where you purchased the evaporative cooler. If for any reason you are not satisfied with the response from the
dealer, contact the Customer Service Department: Champion Cooler, 5800 Murray Street, Little Rock, Arkansas 72209. 1-800-
643-8341. E-mail: info@championcooler.com.
This limited warranty applies to original purchaser only.
4
WINTER SHUT DOWN
• Drain water. Always drain all of the water out of the cooler
and water supply line when not in use for prolonged periods,
and particularly at the end of the season. Keep the water line
disconnected from both the unit and water supply so that it
does not freeze.
• Unplug motor and pump. When cooler is not used for ex-
tended periods, unplug the motor and pump from inside cooler.
• Cover unit. To protect the life of the finish, a cover for the
unit is suggested in extended periods of non use.
3 LB.
By following the operating, installation, and maintenance sug-
3/4 INCHES
gestions as outlined, you can get many years of efficient and
satisfactory service from your cooler. In the event additional
information is desired, your dealer will be more than glad to as-
sist you in every possible way.
FIG. 13

LIMITED WARRANTY

110503