Summary of Contents for MULTIQUIP Whisperwatt Dca20spxu2
Page 1
OperatiOn and parts Manual SERVPRO ® WhisperWatt™ series MODeL Dca20spxu2 60hz generatOr (isuzu BV-4Le2 DieseL engine) parts List nO. M1870301404 NOTICE This generator is manufactured for SERVPRO ® Multiquip, Inc. Revision #0 (09/23/13) THIS MANUAL MUST ACCOMPANY THE EQUIPMENT AT ALL TIMES.
If you believe that your vehicle has a defect that could cause a crash or could cause injury or death, you should immediately inform the National Highway Traffic Safety Administration (NHTSA) in addition to notifying Multiquip at 1-800-421-1244. If NHTSA receives similar complaints, it may open an investigation, and if it finds that a safety defect exists in a group of vehicles, it may order a recall and remedy campaign.
, 2006 order via internet (dealers only) Best deal! If you have an MQ Account, to obtain a Username Order parts on-line using Multiquip’s SmartEquip website! and Password, E-mail us at: parts@multiquip. com. I View Parts Diagrams I Order Parts To obtain an MQ Account, contact your District Sales Manager for more information.
Could result in deatH or serious inJurY. Caution Indicates a hazardous situation which, if not avoided, Could result in minor or moderate inJurY. NOTICE Addresses practices not related to personal injury. PagE 6 — DCa20SPxu2 SERVPRO • operation and parts manual — rev. #0 (09/23/13) ®...
alWaYs store equipment properly when it is not being used. Equipment should be stored in a clean, dry location out of the reach of children and unauthorized personnel DCa20SPxu2 SERVPRO • operation and parts manual — rev. #0 (09/23/13) — page 7 ®...
never touch the hot exhaust manifold, local Health and Safety Administrator. muffl er or cylinder. Allow these parts to cool before servicing equipment. PagE 8 — DCa20SPxu2 SERVPRO • operation and parts manual — rev. #0 (09/23/13) ®...
Use the trailer’s swivel jack to adjust the trailer height to alWaYs shutdown engine before transporting a level position while parked. DCa20SPxu2 SERVPRO • operation and parts manual — rev. #0 (09/23/13) — page 9 ®...
alWaYs recharge the battery in a well-ventilated possibility exists of electrical shock, environment to avoid the risk of a dangerous concentration electrocution or death. of combustible gasses. page 10 — dCa20spxu2 servpro • operation and parts manual — rev. #0 (09/23/13) ®...
Page 11
Recyclers and manufacturers alike promote the process of recycling metal. Using a metal recycling center promotes energy cost savings. DCa20SPxu2 SERVPRO • operation and parts manual — rev. #0 (09/23/13) — page 11 ®...
72.83 in. (1,850 mm.) 21.06 in. (535 mm.) 39.37 in. (1,000 mm.) 24.21 in. (615 mm.) 29.53 in. (750 mm.) 26.38 in. (670 mm.) 25.00 in. (635 mm.) DCa20SPxu2 SERVPRO • operation and parts manual — rev. #0 (09/23/13) — page 13 ®...
EARTH GROUND. CONNECT TO BUILDING GROUND IF GROUND CABLE APPLICABLE N I M REFERENCE 8 ’ ( NEC 250-83 (C) Figure 2. Typical Generator Grounding Application page 14 — dCa20spxu2 servpro • operation and parts manual — rev. #0 (09/23/13) ®...
NFPA 110, Chapter 5-4.1). do not remove the metal skids on the bottom of the generator. They are to resist damage to the bottom of the generator and to maintain alignment. DCa20SPxu2 SERVPRO • operation and parts manual — rev. #0 (09/23/13) — page 15 ®...
This generator is equipped with the state of the art “open- The MQ Power Model DCA20SPXU2 generator (Figure 3) Delta” excitation system. The open delta system consist is a high quality portable (requires a trailer for transport)
5. side reflectors — There are two amber reflectors located on the side of the trailer. These reflectors provide better visibility in dark conditions. page 18 — dCa20spxu2 servpro • operation and parts manual — rev. #0 (09/23/13) ®...
6. aC voltmeter — Indicates the output voltage present at the U,O, and V Output Terminal Lugs. DCa20SPxu2 SERVPRO • operation and parts manual — rev. #0 (09/23/13) — page 19 ®...
INCREASE DECREASE AUTO MANUAL OFF/RESET LOW OIL PRESSURE HIGH COOLANT TEMPERATURE OVERCRANK OVERSPEED ENGINE RUNNING MOOOOO-20001Q 1000 2000 3000 Figure 6. Engine Control Panel PagE 20 — DCa20SPxu2 SERVPRO • operation and parts manual — rev. #0 (09/23/13) ®...
Page 21
Over Crank Protection mode. If the engine engages at a speed (RPM's) that is not safe, the controller will shutdown the engine by initializing the Over Speed Protection mode. DCa20SPxu2 SERVPRO • operation and parts manual — rev. #0 (09/23/13) — page 21 ®...
120 VAC, 20 AMP GFCI RECEPTACLES ACCESS DOOR LIFT TO OPEN RECEPTACLE CIRCUIT BREAKER PANEL CS-6369 TWIST-LOCK AUX. POWER RECEPTACLES 120/240V, 50 AMPS Figure 7. Output Terminal Panel PagE 22 — DCa20SPxu2 SERVPRO • operation and parts manual — rev. #0 (09/23/13) ®...
Page 23
There are two 120/240V, 50 amp auxiliary twist-lock (CS- 6369) receptacles (Figure 9) provided on the output terminal panel.. Figure 11. Plastic Face Plate (Output Terminal Lugs Figure 9. 120/240V Twist-Lock Auxiliary Receptacles DCa20SPxu2 SERVPRO • operation and parts manual — rev. #0 (09/23/13) — page 23 ®...
Page 24
ON/OFF switch. do not use the circuit breakers on the generator as a method of turning the load ON and OFF. Figure 12. Connecting Loads PagE 24 — DCa20SPxu2 SERVPRO • operation and parts manual — rev. #0 (09/23/13) ®...
100 ft. 1800 3600 150 ft. 100 ft. 65 ft. 2400 4800 125 ft. 75 ft. 50 ft. CAUTION: Equipment damage can result from low voltage DCa20SPxu2 SERVPRO • operation and parts manual — rev. #0 (09/23/13) — page 25 ®...
Use voltage regulator adjustment knob whenever fine tuning of the output voltage is required. Figure 15. Voltage Regulator Knob PagE 26 — DCa20SPxu2 SERVPRO • operation and parts manual — rev. #0 (09/23/13) ®...
API Service Classification CC/SD API Service Classification CC/SE API Service Classification CC/SF table 9. recommended motor oil INTERNAL FUEL TANK Figure 18. Trailer Fuel Tank DCa20SPxu2 SERVPRO • operation and parts manual — rev. #0 (09/23/13) — page 27 ®...
Page 28
If adding coolant/antifreeze mix to the radiator, do not remove the radiator cap until the unit has completely cooled. The possibility of hot! coolant exists which can cause severe burns. PagE 28 — DCa20SPxu2 SERVPRO • operation and parts manual — rev. #0 (09/23/13) ®...
A slack fan belt may contribute to overheating, or to insufficient charging of the battery. Inspect the fan belt for DCa20SPxu2 SERVPRO • operation and parts manual — rev. #0 (09/23/13) — page 29 ®...
Pay close attention to the polarity of the battery when connecting the battery. Caution Inadequate battery connections may cause poor starting of the generator, and create other malfunctions. page 30 — dCa20spxu2 servpro • operation and parts manual — rev. #0 (09/23/13) ®...
4. Close all engine enclosure doors (Figure 25). 4. The generator’s AC-voltmeter (Figure 29) will display the generator’s output in volts. CORRECT INCORRECT Figure 25. Engine Enclosure Doors Figure 29. Voltmeter DCa20SPxu2 SERVPRO • operation and parts manual — rev. #0 (09/23/13) — page 31 ®...
Page 32
TEMP DATCON Figure 33. Coolant Temperature Gauge 9. The tachometer gauge (Figure 34) will indicate the speed of the engine when the generator is operating. page 32 — dCa20spxu2 servpro • operation and parts manual — rev. #0 (09/23/13) ®...
Figure 38. Main, Aux. and GFCI Circuit Breakers (OFF) 2. Let the engine cool by running it at low speed for 3-5 minutes with no load applied. page 34 — dCa20spxu2 servpro • operation and parts manual — rev. #0 (09/23/13) ®...
RED meaning the element needs changing or service. After changing the air element, press the dust indicator button to reset the indicator. DCa20SPxu2 SERVPRO • operation and parts manual — rev. #0 (09/23/13) — page 35 ®...
Page 36
To restart after running out of fuel, turn the switch to the on position for 15-30 seconds. Try again, if needed. Figure 41. Fuel Tank Cleaning page 36 — dCa20spxu2 servpro • operation and parts manual — rev. #0 (09/23/13) ®...
Allow engine to cool when flushing out radiator. Flushing the radiator while hot could cause serious burns from water or steam. DCa20SPxu2 SERVPRO • operation and parts manual — rev. #0 (09/23/13) — page 37 ®...
Page 38
REFERENCE TABLE 7 FOR PROPER SIZE EXTENSION CORD CONNECT TO EXTERNAL 120 VAC POWER SOURCE Figure 43. Battery Charger and Jacket Water Heater Power Connections page 38 — dCa20spxu2 servpro • operation and parts manual — rev. #0 (09/23/13) ®...
(the spindle nut motion The possibility exists of the wheels falling off causing will be limited by the cotter pin). equipment damage and severe bodily harm even death! DCa20SPxu2 SERVPRO • operation and parts manual — rev. #0 (09/23/13) — page 39 ®...
If the trailer is involved in an accident, have it inspected immediately by qualified personnel. In addition, the trailer should be inspected annually for signs of wear or deformations. PagE 40 — DCa20SPxu2 SERVPRO • operation and parts manual — rev. #0 (09/23/13) ®...
Allow plenty of room for passing. A rule of thumb is that • Tires are not visibly low on pressure. the passing distance with a trailer is 4 times the passing distance without the trailer. DCa20SPxu2 SERVPRO • operation and parts manual — rev. #0 (09/23/13) — page 41 ®...
Page 42
Be sure your hitch and tow vehicle are rated for the The trailer VIN tag contains the critical safetyinformation Gross Vehicle Weight Rating of your trailer. PagE 42 — DCa20SPxu2 SERVPRO • operation and parts manual — rev. #0 (09/23/13) ®...
Page 43
Also, before you start towing, adjust the mirrors so you can see the trailer as well as the area to the rear of it. DCa20SPxu2 SERVPRO • operation and parts manual — rev. #0 (09/23/13) — page 43 ®...
Page 44
PagE 44 — DCa20SPxu2 SERVPRO • operation and parts manual — rev. #0 (09/23/13) ®...
Page 45
Figure C. Ball Hitch Coupler Before each tow, coat the ball with a thin layer of automotive bearing grease to reduce wear and ensure proper operation. DCa20SPxu2 SERVPRO • operation and parts manual — rev. #0 (09/23/13) — page 45 ®...
Page 46
In the open position, the coupler is able to drop fully onto the hitch ball. PagE 46 — DCa20SPxu2 SERVPRO • operation and parts manual — rev. #0 (09/23/13) ®...
Page 47
Before towing the trailer check for the following: Running lights (turn on tow vehicle headlights). Brake Lights (step on tow vehicle brake pedal). DCa20SPxu2 SERVPRO • operation and parts manual — rev. #0 (09/23/13) — page 47 ®...
Page 48
Be sure the coupler is secured tightly to the tongue of the of the latching mechanism. trailer. All coupler fasteners must be visibly solid against the trailer frame. PagE 48 — DCa20SPxu2 SERVPRO • operation and parts manual — rev. #0 (09/23/13) ®...
Page 49
Using the trailer jack, test to see that you can raise the rear of the tow vehicle by1-inch after the coupler is locked to the hitch. DCa20SPxu2 SERVPRO • operation and parts manual — rev. #0 (09/23/13) — page 49 ®...
Page 50
On all trailers there is a Federal certifi cation/VIN label that is located on the forward half of the left (road) side of the unit. page 50 — dCa20spxu2 servpro • operation and parts manual — rev. #0 (09/23/13) ®...
Page 51
P: The “R” stands for radial. Radial ply construction of tires tread separation or blowout and fl at tires. These actions, has been the industry standard for the past 20 years. DCa20SPxu2 SERVPRO • operation and parts manual — rev. #0 (09/23/13) — page 51 ®...
Page 52
Figure J. UTQGS Tire Information tire ply Composition and materials used: The number of plies indicates the number of layers of rubber-coated fabric page 52 — dCa20spxu2 servpro • operation and parts manual — rev. #0 (09/23/13) ®...
Page 53
Punctures through the tread can be repaired if they are not too large, but punctures to the DCa20SPxu2 SERVPRO • operation and parts manual — rev. #0 (09/23/13) — page 53 ®...
Page 54
Improper operating taillights, stoplights and turn signals or permanently deforming the mounting stud holes in can cause collisions. the wheels. Check all lights before each tow. page 54 — dCa20spxu2 servpro • operation and parts manual — rev. #0 (09/23/13) ®...
FREQUENCY METER lead of designated color. CIRCUIT BREAKER CB2,3 CIRCUIT BREAKER CB4,5 CIRCUIT BREAKER CON1, 2 RECEPTACLE CON3,4 RECEPTACLE RESISTOR RECTIFIER J, K RELAY UNIT page 56 — dCa20spxu2 servpro • operation and parts manual — rev. #0 (09/23/13) ®...
Wiring DiagraM COLOR CODE WIRE COLOR WIRE COLOR BLACK BLUE WHITE BROWN YELLOW GREEN LIGHT BLUE GRAY LIGHT GREEN ORANGE VIOLET PINK EMERGENCY STOP SWITCH DCa20SPxu2 SERVPRO • operation and parts manual — rev. #0 (09/23/13) — page 57 ®...
Check wiring and repair. Defective AVR? Replace if necessary. Is wiring connections loose? Check wiring and repair. High Voltage Output Defective AVR? Replace if necessary. DCa20SPxu2 SERVPRO • operation and parts manual — rev. #0 (09/23/13) — page 59 ®...
Correct engine oil level. Use No. 2-D diesel fuel only. Check the fuel Injection pump wear? injection pump element and delivery valve assembly and replace as necessary. PagE 60 — DCa20SPxu2 SERVPRO • operation and parts manual — rev. #0 (09/23/13) ®...
Page 61
Fan, radiator, or radiator cap defective? Replace defective part. Thermostat defective? Check thermostat and replace if necessary. Head gasket defective or water leakage? Replace parts. DCa20SPxu2 SERVPRO • operation and parts manual — rev. #0 (09/23/13) — page 61 ®...
A blank entry generally indicates that the item is not sold assembly/kit that can be purchased, or is not available separately or is not sold by Multiquip. Other entries will for sale through Multiquip. be clarifi ed in the “Remarks” Column.
70 — dCa20spxu2 servpro • operation and parts manual — rev. #0 (09/23/13) ®...
Page 71
AIR CLEANER INDICATOR 0602040552 AIR CLEANER BRACkET 0016908030 HEX HEAD BOLT M1373100303 AIR CLEANER HOSE M1373100503 AIR CLEANER HOSE 0605515139 HOSE BAND 0602022560 ADAPTER M1320300304 PACkING DCa20SPxu2 SERVPRO • operation and parts manual — rev. #0 (09/23/13) — page 71 ®...
Page 72
(cOntinueD) page 72 — dCa20spxu2 servpro • operation and parts manual — rev. #0 (09/23/13) ®...
Page 73
TACHOMETER PICk UP 0602122272 OIL PRESSURE UNIT M9200100004 ADAPTER 0602123275 WATER TEMPERATURE UNIT M1353800004 CLAMPER ROD 0016908020 HEX HEAD BOLT M1357300104 CLAMPER ROD 0016910020 HEX HEAD BOLT DCa20SPxu2 SERVPRO • operation and parts manual — rev. #0 (09/23/13) — page 73 ®...
WHITE. Once the panel has been received it should be painted Sherwin-Williams (SERVPRO Green), Product PGS ® 860083, color Pantone 368C page 74 — dCa20spxu2 servpro • operation and parts manual — rev. #0 (09/23/13) ®...
(traiLer MOunteD) RETURN FROM ENGINE TO RACOR FUEL FILTER TO INTERNAL FUEL TANK PagE 82 — DCa20SPxu2 SERVPRO • operation and parts manual — rev. #0 (09/23/13) ®...
Page 83
6109210 BOLT, 1/2-13 X 1-1/2" 13211 WASHER, FLAT 1/2 X 1-1/4 USS 6109160 NUT, 1/2" 6109810 WASHER, LOCk 1/2" 6109170 WASHER, FLAT 1/2 X 1 DCa20SPxu2 SERVPRO • operation and parts manual — rev. #0 (09/23/13) — page 83 ®...
WHITE. Once the panel has been received it should be painted Sherwin-Williams (SERVPRO Green), Product PGS ® 860083, color Pantone 368C page 90 — dCa20spxu2 servpro • operation and parts manual — rev. #0 (09/23/13) ®...
Page 91
HEX HEAD BOLT M3310600004 ROOF COVER 0019208020 HEX HEAD BOLT M1453201202 SPLASHER PANEL 0019108055 HEX HEAD BOLT 0042308000 WASHER, LOCk 0042408000 WASHER, FLAT 0016908020 HEX HEAD BOLT DCa20SPxu2 SERVPRO • operation and parts manual — rev. #0 (09/23/13) — page 91 ®...
Page 92
WHITE. Once the panel has been received it should be painted Sherwin-Williams (SERVPRO Green), Product PGS ® 860083, color Pantone 368C page 92 — dCa20spxu2 servpro • operation and parts manual — rev. #0 (09/23/13) ®...
94 — dCa20spxu2 servpro • operation and parts manual — rev. #0 (09/23/13) ®...
Page 95
SEAL RUBBER 0228800525 SEAL RUBBER 0228800565 SEAL RUBBER 0228100458 SEAL RUBBER 0228100171 SEAL RUBBER 0228100351 SEAL RUBBER 0228100285 SEAL RUBBER 0228100153 SEAL RUBBER 0228100180 SEAL RUBBER DCa20SPxu2 SERVPRO • operation and parts manual — rev. #0 (09/23/13) — page 95 ®...
If the unit is covered under warranty, the RMA Coordinator will communicate the repair and return process. Servpro RMA Department is here to serve you! ® DCa20SPxu2 SERVPRO • operation and parts manual — rev. #0 (09/23/13) — page 101 ®...
Page 102
OperatiOn and parts Manual SERVPRO SERVPRO INDUSTRIES INC. ® 801 Industrial Blvd. Gallatin, TN 37066 Phone: 615-451-0200...