Nameplate And Decals Assembly - MULTIQUIP GA-9.7HE Operation And Parts Manual

WARNING
To avoid injury,
you MUST read
and understand
operator's manual
1
before using this
machine.
This machine to
be operated by
qualified
personnel only.
Ask for training
as needed.
12
11
10
OIL DRAIN
CAUTION
9
Before starting the engine, check that the oil
level is within the indicated operating range.
If the level is above the H mark or below
the L mark, it is important to correct before
operating to avoid damage.
DANGER
EXPLOSIVE GASES
Cigarette flames or sparks could cause battery to explode. Always
shield eyes and face from battery. Do not charge or use booster cables
or adjust post connections without proper instructions and training.
8
KEEP VENT CAPS TIGHT AND LEVEL
POISON
CAUSES SEVERE BURNS
Contains sulfuric acid. Avoid contact with skin, eyes or clothing. In
event of accident flush with water and call a physician immediately.
KEEP OUT OF THE REACH OF CHILDREN
page 36 — ga9.7He 60 Hz geNeRaTOR• OpeRaTiON aNd paRTs maNual — Rev. #1 (04/29/10)
ga9.7He— naMeplate and deCals assy.
DANGER
OPERATE AT
3600 RPM ONLY
Do not touch output terminals or
internal wiring while unit is operating.
(
FULL THROTTLE
Turn off power before servicing.
S-4985
Only qualified personnel should
ELECTRICAL DAMAGE MAY RESULT IF
install, use or service this
SHOCK
OPERATED AT LOWER SPEEDS
HAZARD equipment.
WARNING
WARNING
B e f o r e c o n n e c t i n g t h i s
Only operate machine in well ventilated
g e n e r a t o r t o a n y b u i l d i n g ' s
areas.
e l e c t r i c a l s y s t e m , a l i c e n s e d
DO NOT inhale exhaust gases. e l e c t r i c i a n m u s t i n s t a l l a n
i s o l a t i o n ( t r a n s f e r ) s w i t c h .
S-4984 Only qualified personnel should
install, use or service this S e r i o u s i n j u r y o r d e a t h m a y
Only qualified personnel should
DANGEROUS r e s u l t w i t h o u t t h i s t r a n s f e r
install, use or service this
equipment.
GAS s w i t c h .
equipment.
AC CIRCUIT BREAKER
for 120V for 120V
15A 30A
S-1123
DANGER
THE POSSIBILITY EXISTS OF ELECTROCUTION IF
GENERATOR/WELDER IS NOT PROPERLY GROUNDED.
ALWAYS CONNECT EARTH GROUND (GROUND
ROD) TO GENERATOR GROUND POINT.
0N
OFF V 120 OFF ON
6000 CONTROL IDLE
120V
21A OPERATION OFF
AC CIRCUIT SWITCH GROUND
GA-6H BREAKER 120V/240V 20A
120/240V 120V FULL POWER SWITCH
30A 30A 20A
SCREW
GROUND
CABLE
#8 MINIMUM
GROUND ROD
FOR EARTH
GROUND
CONNECT TO
BUILDING
GROUND
IF REQUIRED
FOR FURTHER GROUNDING 8 FT. MINIMUM
INSTRUCTIONS, READ MANUAL
REFERENCE
NEC 250-52(C)
D9531100104
OIL LEVEL GAUGE
H
L
FUEL DRAIN
OPERATING INSTRUCTIONS
CAUTION
1. Before starting check the oil and fuel level.
2. Switch the circuit breaker to the "OFF" position.
)
3. Pull the choke knob.
4 . Turn the operation switch to the "ON" position
and push the start button to start the engine.
5 . After the engine starts, gradually push in the choke knob.
6 . Run the generator for 3-5 minutes without load.
7 . Check for any abnormal noise or smell.
8 . Switch the circuit breaker to the "ON" position.
9 . When stopping, cut-off the load and allow the unit
to cool for 2-3 minutes before stopping engine.
1 .Turn the operation switch to the "OFF" position. 0
A91110010
120 ON ON 9700
V 240
GA-9.7HE
OFF
OFF
IDLE CONTROL OPERATION START
SWITCH BUTTON
SWITCH
for 240V for 120/240V AC VOLTMETER
20A 30A
OFF OFF
120V 240V 120/240V
35A
35A
AC CIRCUIT
BREAKER
(for main)
DANGER
Using a generator indoors CAN KILL YOU IN MINUTES .
Utilser un générateur à l' intérieur VOUS TUERA EN QUELQÙES MINUTES.
Exhaust contains carbon monoxide, a poison gas you cannot see or smell.
Les gaz d' échappement contiennent du monoxyde de carbon, un gaz toxique
invisible et inodore.
GAC-2.2H NEUTRAL BONDED TO FRAME
POWERED by Honda Engines 15A 120V 120 V NEUTRE MIS A LA MASSE A LA CARCASSE DU MOTEUR GAC-2.2H POWERED by Honda Engines 120V 15A V 120 LA CARCASSE DU MOTEUR NEUTRAL BONDED TO FRAME NEUTRE MIS A LA MASSE A
211052 GR PRISE DE TERRE INTERRUPTEUR DE COURANT PRINCIPAL AC CIRCUIT BREAKER 211052 GR PRISE DE TERRE INTERRUPTEUR DE COURANT PRINCIPAL AC CIRCUIT BREAKER GAC-2.2H 15A 120V NEUTRE MIS A LA MASSE A LA CARCASSE DU MOTEUR 120 V NEUTRAL BONDED TO FRAME
GR PRISE DE 211052 Honda Engines POWERED by COURANT PRINCIPAL INTERRUPTEUR DE AC CIRCUIT BREAKER
TERRE
ONLY use outdoors and away from
NEVER use in enclosed or partially
open windows, doors, and vents.
enclosed areas.
Utilisation UNIQUEMENT à l' extér leur
Utilisation INTERDITE dans un
portes et trous d' aération
espace clos ou partiellement clos.
A90400001
9700
GA-9.7HE
7
2
D25200040B
CAUTION
HOT PARTS can burn skin.
DO NOT touch until the
lamp has sufficiently cooled.
B90400030
WARNING
Operation of this equipment may create
sparks that can start fires around dry
vegetation.
A spark arrestor may be required.
The operator should contact local fire
agencies for laws or regulation relating
to fire prevention requirements.
A91110010
S/N 5619690 AND ABOVE
5
6
3
4