Table Of Contents - Frymaster 17EC Installation, Operation & Service Parts Manual

ELECTRIC COOKER MODELS 17EC, 17ECS, ESW AND EWBS
CHAPTER 1: General Information
1.1 Parts Ordering and Service Information
1.2 Safety Information
1.3 Equipment Description
1.4 Installation, Operating, and Service Personnel
1.5 Definitions
1.6 Shipping Damage Claim Procedure
CHAPTER 2: Installation Instructions
2.1 General Installation Requirements
2.2 Caster/Leg Installation
2.3 Pre-Connection Preparations
2.4 Connection to the Electrical Power Supply
CHAPTER 3: Operating Instructions
3.1 Spaghetti Magic II Controller (As Used on 17EC and 17ECS Units)
3.2 Computer Magic III Controller (As Used on EWBS Units)
3.3 Thermostat Control and Switch Panel (As Used on ESW and EWBS Units)
3.4 Boiling Out the Cookpot
CHAPTER 4: Preventive Maintenance
Daily Preventive Maintenance
CHAPTER 5: Operator Troubleshooting
5.1 Introduction
5.2 Operator Troubleshooting Guide
5.3 Replacing the Controller (17EC/17ECS and EWBS with CM III Computer)
5.4 Replacing Fuses in 17EC and 17ECS Models
CHAPTER 6: 17EC/17ECS Service Procedures & Parts
6.1 Functional Description ................................................................................................... 6-1
6.2 Accessing Equipment for Servicing ............................................................................... 6-2
6.3 Replacing Equipment Components ................................................................................ 6-2
6.3.1 Replacing the Computer ................................................................................................. 6-2
6.3.2 Replacing Electronic Components Other than the Computer ........................................ 6-2
6.3.3 Replacing a Heating Element ......................................................................................... 6-3
6.3.4 Replacing the High-Limit Thermostat ........................................................................... 6-5
6.3.5 Replacing a Water-Level Sensor .................................................................................... 6-6
6.3.6 Replacing the Temperature Probe .................................................................................. 6-6
6.3.7 Replacing the Pressure Regulator or Solenoid Valve .................................................... 6-7
6.3.8 Replacing the Water Faucet ........................................................................................... 6-7
6.3.9 Replacing a Basket Lift Motor or Microswitch.............................................................. 6-8
6.3.10 Replacing the Cookpot or Rinse Tank ........................................................................... 6-9
6.4 Technician Troubleshooting......................................................................................... 6-11

TABLE OF CONTENTS

i
1-1
1-1
1-2
1-3
1-3
1-4
2-1
2-2
2-2
2-3
3-1
3-3
3-8
3-9
4-1
5-1
5-2
5-3
5-4