Table of Contents
Advertisement
The appliance
may be installed
in an aftermarket
permanently
located,
manufactured
(mobile)
home, where not prohibited
by local codes. This appliance
is only for use with the type of gas
indicated
on the rating
plate.
This appliance
is not convertible
for use with other gases, unless a
certified kit is used.
CONTENTS
Introduction
.....................................
2
Specifications
and Dimensions ...............
2
Safety Rules .....................................
3
Clearances .......................................
4, 5
Location ..........................................
6
Installation .......................................
6
Operation ........................................
7
Lighting Instructions ...........................
8, 9
Pilot Adjustment ................................
10
Removing Burner ............................
10
Proper Burner Flame ........................
10
Optional Side Discharge Kit ...............
14
Terminal Block Wiring .....................
13
Manual Reset .................................
13
Maintenance Instructions ...................
13
Trouble Shooting .............................
16,17
Pans Drawing .................................
18
Parts List .......................................
19,20
Warranty .......................................
22
INTRODUCTION
Read these installation
and operating instructions
carefully before you install or attempt to use this Direct
Vent Counterflow Wall Furnace. If you do not understand any part of the instructions, consult local authorities,
a qualified installer, service agency or the gas supplier. FAILURE
TO READ OR UNDERSTAND
THESE
INSTRUCTIONS
CAN RESULT
IN MALFUNCTION,
INEFFICIENT
OPERATION,
PROPERTY
DAMAGE,
SERIOUS
INJURY OR DEATH.
SPECIFICATIONS
AND DIMENSIONS
Your Direct Vent Counterflow
Wall Furnace is shipped in two cartons.
One carton contains the furnace,
thermostat, thermostat
wire and insulated staples. The second carton will have the vent tube, air intake tube
and vent cap assembly.
After the furnace has been removed from the carton check the rating plate to verify
that the model number is correct and that the wall furnace is equipped with the type gas you intend to use.
Model
Type
Type
Btu/Hr. Gas
Blower
Approx.
Number
Control Gas
Input
Inlet
Finished Dimensions
Speed
Amps
CFM
Ship. Wt
24 VOLT
SYSTEM
WITH
LOW-BTU
STANDING
PILOT
DVCF403B-R
24¼)1t
Nat.
40,000
½"
DVCF404B-R
24Volt
L.P
40,000
½"
DVCF653B-R
24¼_1t Nat.
62,500
½"
DVCF654B-R
24¼_1t L.P
62,500
½"
14-5/16"Wx78-5/8"Hxl 1-3/4"D
1
1.95
320
128 Lbs.
14-5/16"Wx78-5/8"Hxl 1-3/4"D
1
1.95
320
128 Lbs.
14-5/16"Wx87-5/16"tLxl 1-3/4"D
2
3.05
440
142 Lbs.
14-5/16"Wx87-5/16"tLxl 1-3/4"D
2
3.05
440
142 Lbs.
24 VOLT SYSTEM
WITH INTERMITTENT
IGNITION
(I.I.D.)
DVCF407B-R
24¼_1t
Nat.
40,000
½"
14-5/16"Wx78-5/8"Hxll-3/4"D
1
2.2
320
130Lbs.
DVCF408B-R
24¼_1t
L.P
40,000
½"
14-5/16"Wx78-5/8"Hxll-3/4"D
1
2.25
320
130Lbs.
DVCF557B-R
24¼_1t
Nat.
55,000
½"
14-5/16"Wx87-5/16"ILxll-3/4"D
2
3.3
440
144Lbs.
DVCF558B-R
24¼)1t
L.P
55,000
½"
14-5/16"Wx87-5/16"Hxll-3/4"D
2
3.35
440
144Lbs.
Page 2
Advertisement
Table of Contents
