Download Print this page
All-Power APG3006 Owner's Manual

All-Power APG3006 Owner's Manual

1050 watt portable generator

Advertisement

Quick Links

1050WATT P ORTABLE
GENERATOR
866.393,3968
866.393.3968

Advertisement

loading
Need help?

Need help?

Do you have a question about the APG3006 and is the answer not in the manual?

Questions and answers

Subscribe to Our Youtube Channel

Summary of Contents for All-Power APG3006

  • Page 1 1050WATT P ORTABLE GENERATOR 866.393,3968 866.393.3968...
  • Page 2 1050W 4 StrokeGenerator Tableof Contents 1. DESCRIPTION 2. UNPACKING 3. GENERAL SAFETY 4. OPERATION PRE-OPERATION GROUNDING DC APPLICATION STARTING ENGINE BREAK-IN GENERATOR SHUT LOAD AND PROTECTOR OIL WARNING SYSTEM 5, MAINTENANCE INFREQUENT USAGE STORAGE- MAINTENANCE SCHEDULE 6, TROUBLESHOOTING 7. WIRING DIAGRAM 8.
  • Page 3 1050W 4 StrokeGenerator Description This generator is powered by an air-cooled, four-stroke, OHV engine. 1. Fuel tank cap 2. Safty label 3.Control panel 4.Generator nameplate 5. Starting handle 6. Fuel petcock 7. Carburetor choke lever 8. DC circuit fuse 9. AC circuit fuse 121314 10.
  • Page 4 1050W 4 StrokeGenerator Description OIL FILLER CAP 13. Never operate the generator with damaged, (OIL GAUGE) broken or missing parts. DO NOT operate the generator while any of the protective shrouds or guards are removed. 14. Do not refill the fuel tank while the engine is running.
  • Page 5 4 StrokeGenerator Grounding 1. Use the ground terminal on STARTING the generator to connect the 1. Remove all electrical loads from the generator. unit to a suitable ground source. Securely fasten the 2. Set the fuel switch to the open (ON) position. end terminal of the ground wire 3.
  • Page 6 1050W 4 StrokeGenerator Operation LOAD AND PROTECTOR Engine switch to Off position to RUN position ENGINE BREAK-IN The break-in period for the generator's engine is the first 25 hours of operation. During this timeframe, DO NOT exceed 75% of the generator's load limit.
  • Page 7 1050W 4 StrokeGenerator Maintenance INFREQUENT USAGE If the generator is used infrequently, starting 4. Pour approximately one teaspoon of oil into difficulties may occur. To help prevent this spark plug hole. from happening, the generator should be 5. Pull starter cord several times to spread the started and run for approximately 30 minutes oil throughout...
  • Page 8 1050W 4 StrokeGenerator Maintenance MAINTENANCESCHEDULE Before First Every Every 6 Every months months Months Part Item every month or 50 or 100 or 300 starting 20 hours hours hours hours Check condition, adjust and clean. Spark plug Replace or fill if necessary Check oil level.
  • Page 9 1050W 4 StrokeGenerator TroubleShooting Problem Possible Cause Corrective Action 1. Adjust engine speed(ask repair 1. Engine speed is too slow shop for help) 2. Open or shorted wiring 2. Clean and reconnect all wiring Zero output from 3. Faulty capacitor 3.
  • Page 10 1050W 4 StrokeGenerator WiringDiagram C-BOX ENG.SW. ! ! _"rll ..Lc ;:::13 " "BL SOCKET +_'] DC m ENGINE AC WINDING BLACKAND WHITE OIL SENDING UNIT AUXILIARY WINDING BLACK SPARK PLUG CHARGING WINDING GREEN GENERATOR PILOT LAMP DI/D2 RECTIFIER AC SOCKET YELLOW AC FU AC FUSE...
  • Page 11 1050W 4 StrokeGenerator Parts List...
  • Page 12 GB5781 M8"16 Washer GB97.2 Oit alarmer Spring washer GB93 Muffler GR1000C.01.02-00 GB/T6170 Muffter guided cover GR1000C.03-01 Bolt GB/T818 M5"I0 (inside) FOR TECHNICAL SUPPORT PLEASE _III_ 866.393.3968 All-Power America 16273 E. Gale Ave. CityOfIndustry, CA 91745 626.855.0840 www.allpoweramerica.com all rights reserved...