1. Manuals
  2. Brands
  3. Centro Manuals
  4. Grill
  5. Barbecue 3000 Safe use
  6. Safe use, care and assembly manual

Centro Barbecue 3000 Safe Use, Care And Assembly Manual

Hide thumbs Also See for Barbecue 3000:
Table of Contents

Advertisement

Quick Links

Download this manual
SERIAL #:
5 - Y E A R L I M I T E D W A R R A N T Y
8 5 - 1 1 1 4 - 2 ( P R O P A N E ) ( G 5 0 2 1 2 )
8 5 - 1 0 9 9 - 8 ( N A T U R A L G A S ) ( G 5 0 2 1 4 )
Read and save this manual for future reference.
If pre-assembled, leave this manual with
unit for consumer's future reference.
For product inquiries, parts, warranty
and troubleshooting please call
1-877-707-5463
Barbecue 3000
S A F E U S E , C A R E A N D A S S E M B L Y M A N U A L
D A N G E R
If You Smell Gas
1. Shut off gas to the appliance.
2. Extinguish any open flame.
3. Open lid.
4. If odor continues, keep away from the
appliance and immediately call your
gas supplier or your fire department.
W A R N I N G
1. Do not store or use gasoline or other
flammable liquids or vapors in the
vicinity of this or any other appliance.
2. An LP cylinder not connected for use
shall not be stored in the vicinity of
this or any other appliance.
W A R N I N G
Failure to follow all of the manufacturer's
instructions could result in hazardous
fires, explosions, property damage,
or serious personal injury or even death.
W A R N I N G
Follow all leak check procedures carefully
prior to operation of barbecue,
even if barbecue was store assembled.
Do not try to light this barbecue
without reading the Lighting Instructions
section of this manual.
T H I S B A R B E C U E I S F O R
O U T D O O R U S E O N L Y

Advertisement

Table of Contents
loading

Related Manuals for Centro Barbecue 3000

Summary of Contents for Centro Barbecue 3000

  • Page 1 SERIAL #: Barbecue 3000 S A F E U S E , C A R E A N D A S S E M B L Y M A N U A L D A N G E R If You Smell Gas 1.

  • Page 2: Table Of Contents

    Warranty ....ii This Centro BBQ carries a five year limited warranty against defects in manufacturing work- Installation Information ..1 manship.

  • Page 3: Installation Information

    I N S T A L L A T I O N The installation of this appliance must be in accordance with all local codes, or in the absence of local codes: I N F O R M A T I O N Canadian installation must conform to the current national standards, which at this time •...

  • Page 4: Transportation And

    The Cylinder must also be equipped with: A shut-off valve with a correct cylinder valve outlet as specified in current standards. • Canada: CAN / CGA 1.6g-M97 Outdoor Gas Grilles. • a) A safety relief valve with direct connection to the vapour space of the cylinder. b) A collar to protect the tank shut-off valve.

  • Page 5: Prior To Using The Grill

    P R I O R T O U S I N G Do not use your barbecue until you have carefully read and fully understand all the information in this manual. Please ensure the following: Your barbecue is properly assembled. •...

  • Page 6: Safety Hose And Regulator

    S A F E T Y H O S E Propane Gas Models: Your barbecue is designed to operate on L.P. (Propane) gas at a pressure of 2.74 Kpa (11˝ water column). A regulator preset to this pressure is supplied A N D R E G U L A T O R with the barbecue and must be used.

  • Page 7: Safety Leak Testing

    To Reset The Gas Regulator Safety Device 1. Close the LP (propane) tank valve. 2. Turn all burner control knobs to the OFF position. 3. Disconnect the regulator from the LP tank. 4. Open the grill lid. 5. Open all of the control knobs to the high position. 6.

  • Page 8: Lighting The Grill

    L I G H T I N G Make Sure you have followed all the safety checks, procedures and instructions indicated in the previous section, before attempting to light the grill. T H E G R I L L Lighting The Main Burners 1.
  • Page 9 6. Confirm that the burner is properly lit. If the flame pattern is other than normal, consult the Troubleshooting Guide for corrective action. 7. Always preheat the Barbecue before starting to cook. Light all burners and adjust them to the HIGH position for 5-10 minutes. Before placing any food on the Barbecue, clean the cooking grids with a Porcelain cleaning brush.
  • Page 10 Lighting the Second Burner Turn the second control knob on the main control panel to the • “HIGH” position. The unlit burner will automatically ignite. Lighting the Side Burner Use the Electronic Ignitor located on the main control panel and the far left side burner control knob in this step.

  • Page 11: Information On

    6. If a leak cannot be stopped, do not attempt to light the grill. Always contact Centro Customer Support for assistance. 1-888-707-5463. Gas Hookup & Warnings Warnings: Poor Natural Gas Burning Performance and heat distribution is related to the points listed below..

  • Page 12: Parts List And

    All gas supply plumbing must be able to supply 7” water column to the barbecue with all burners in operation. ALL Centro BBQ’s are sold either NATURAL GAS or PROPANE READY and are not Convertible to an alternate gas source.
  • Page 14 P A R T S L I S T I N G F O R 8 5 - 1 1 1 4 - 2 ( P R O P A N E ) ( G 5 0 2 1 2 ) Item No.
  • Page 15 8 5 - 1 1 1 4 - 2 ( P R O P A N E ) ( G 5 0 2 1 2 )
  • Page 16 P A R T S L I S T I N G F O R 8 5 - 1 0 9 9 - 8 ( N A T U R A L G A S ) ( G 5 0 2 1 4 ) Item No.

  • Page 17: Assembly Instructions

    8 5 - 1 0 9 9 - 8 ( N A T U R A L G A S ) ( G 5 0 2 1 4 )
  • Page 18 A S S E M B L Y I N S T R U C T I O N S Hardware Pack List Description Part Number Quantity Tools Needed for Assembly 1/4” x 38mm Screw 20120-13038-250 1/4” x 13mm Screw 20120-13013-250 Ø7 Lock Washer 41400-07000-250...
  • Page 19 Fig. 1 Attach two front casters (CN) and two back casters with lock (CM) to the bottom shelf (CK) using the wrench #13 provided. Fig. 2 Assemble the left and right cart side panel (CA & CB) to the bottom shelf (CK) as shown using hardware #2 ( X6) (from the top) and #3, #4 and #5 (X6) (from the bottom).
  • Page 20 Place the top lid and burner box assembly (A+B) onto the cart assembly as shown. Attach them using hardware #6, #7 and #8 (x6) to the screw holes as shown. Fig. 4 Fig. 5 Open lid and position the 3 flame tamers (BN) above the 3 main burners (BK &...
  • Page 21 Fig. 7 Insert the left and right grease tray bar (CD & CE) into the holes of upper rail (CJ) as shown. Assemble the upper rear panel (BQ) to the burner box and cart assem- bly using hardware #1, #3 and #4 (x4). Attach the upper rear panel (BQ) to both grease tray rails (CD &...
  • Page 22 Fig. 10 Push the side burner valve stem (BF) and mount it by using screws and washers included on the valve bracket, threading through the side burner control panel. Affix the Bezel (BT) onto the valve stem using hardware provided. Push the knob (BS) onto the valve stem with the arrow on the knob pointing upwards.
  • Page 23 Fig. 10 For propane model only Secure 20 lb propane tank onto the bottom shelf of the cart as shown, attach the regulator valve to 20 lb propane tank. WARNING Do not store extra propane tanks within BBQ cart.
  • Page 24 D I S T R I B U T O R Trileaf Distribution Trifeuil Toronto, Canada M4S 2B8...

Table of Contents