Table of Contents
Advertisement
Quick Links
Barbecue Stainless 4000B
5 Y E A R L I M I T E D W A R R A N T Y
( G 5 0 2 0 2 ) 8 5 - 1 2 5 4 - 8 ( P R O P A N E )
( G 5 0 2 0 4 ) 8 5 - 1 2 1 4 - 4 ( N A T U R A L G A S )
Read and save this manual for future reference.
If pre-assembled, leave this manual with
unit for consumer's future reference.
For product inquiries, parts, and warranty
and troubleshooting support, please call
1 877 707-5463
S A F E U S E , C A R E A N D A S S E M B L Y M A N U A L
F O R Y O U R S A F E T Y
If You Smell Gas
1. Immediately turn off the flow of gas to
the unit.
2. Extinguish any open flame.
3. Open the lid of the unit.
4. If the odour does not stop quickly, immedi-
ately call your gas supplier or Fire
Department for assistance.
F O R Y O U R S A F E T Y
1. Do not store or use gasoline or other
flammable vapours and liquids in the
vicinity of this or other appliance.
2. An LP Gas cylinder not connected for
use shall not be stored in the vicinity
of this or other appliance.
W A R N I N G
Failure to follow all of the manufacturer's
instructions could result in hazardous
fires, explosions, property damage,
or serious personal injury or even death.
W A R N I N G
Follow all leak check procedures carefully prior
to operation of barbecue, even if barbecue
was stored assembled. Do not try to light
this barbecue without reading the Lighting
Instructions section of this man ual.
T H I S B A R B E C U E I S F O R
O U T D O O R U S E O N L Y
Advertisement
Table of Contents
Related Manuals for Centro Barbecue Stainless 4000B
Summary of Contents for Centro Barbecue Stainless 4000B
- Page 1 Barbecue Stainless 4000B S A F E U S E , C A R E A N D A S S E M B L Y M A N U A L F O R Y O U R S A F E T Y If You Smell Gas 1.
-
Page 2: Table Of Contents
Warranty ....ii This Centro BBQ carries a five year limited warranty against defects in manufacturing Installation ....1 workmanship. -
Page 3: Installation
I N S T A L L A T I O N The installation of this appliance must be in accordance with all local codes, or in the absence of local codes: Canadian installation must conform to the current national standards, which at this time •... -
Page 4: Transportation And
The Cylinder must also be equipped with: A shut-off valve with a correct cylinder valve outlet as specified in current standards. • Canada: CAN / CGA 1.6g-M97 Outdoor Gas Grilles. • a) A safety relief valve with direct connection to the vapour space of the cylinder. b) A collar to protect the tank shut-off valve. -
Page 5: Hose And Regulator
H O S E A N D Propane Gas Models: Your barbecue is designed to operate on L.P. (Propane) gas at a pressure of 2.74 Kpa (11˝ water column). A regulator preset to this pressure is supplied R E G U L A T O R with the barbecue and must be used. - Page 6 The Following Must be Checked The tank valve including the threads into the tank (drawing C). • All tank welds (drawing B). • Regulator fittings and tank connections (drawing C). • All hose connections (drawing D). • With a newly filled and tested propane tank attached to the •...
-
Page 7: Lighting The Grill
L I G H T I N G Make sure you have followed all the checks, procedures and instructions • indicated in the prior sections before attempting to light the grill. T H E G R I L L Always raise the barbecue lid before lighting the burner. •... - Page 8 W A R N I N G If the heat output is too low, the flow control feature may have been activated by a gas leak. If so, turn off the burner valve and cylinder valve, and perform the “Leak Test”. If there aren’t any leaks, re-light the burner.
-
Page 9: Tips On Using
T I P S O N U S I N G Using for the First Time: Before cooking, turn on the grill and operate on “HIGH” for about 10–15 minutes with the lid open. Close the lid and continue to run the grill on Y O U R B A R B E C U E “HIGH”... -
Page 10: Cleaning And Maintenance
C L E A N I N G To get many years of service out of your barbecue, perform the following procedures at least once a year, especially at the start of a new season. A N D M A I N T E N A N C E Grill: Apply a light coating of cooking oil to the grating to prevent food from sticking. -
Page 11: Troubleshooting Guide
T R O U B L E S H O O T I N G G U I D E Problem Possible Causes Corrective Action Burner will not light Blocked Venturi tubes Clean out blockage • • (match or igniter) Cylinder or gas supply valve turned off Open cylinder or gas supply valve •... -
Page 12: Parts List And
P A R T S L I S T F O R Item No. Quantity Description Part No. / Spec. Top Lid Assembly 8 5 - 1 2 5 4 - 8 ( P R O P A N E ) Top Lid Weldment G502-0100- 01 Handle –... - Page 13 8 5 - 1 2 5 4 - 8 ( P R O P A N E )
-
Page 14: Parts List And
P A R T S L I S T F O R Item No. Quantity Description Part No. / Spec. Top Lid Assembly 8 5 - 1 2 1 4 - 4 ( N A T U R A L G A S ) Top Lid Weldment G502-0100-01 Handle F/ Top Lid... - Page 15 8 5 - 1 2 1 4 - 4 ( N A T U R A L G A S )
-
Page 16: Assembly Instructions
A S S E M B L Y I N S T R U C T I O N S Hardware Pack List Description Part Number Quantity Tools Needed for Assembly 1/4” x 35 mm Screw 20120-13035-250 1/4” x 13 mm Screw 20120-13013-250 #2 Phillips ®... - Page 17 Attach two front caster assembly (DN) and two back caster assembly with locks (DM) to the bottom shelf weldment (DF), using the wrench (hardware No.14) and twist the casters into the shelf. Assemble lower left side panel (DC) and lower right side panel (DD) to the bottom shelf weldment, using hardware No.
- Page 18 Assemble the top lid assembly (A) and burner box assembly (C ) to the cart assembly (D). Attach both Upper Side Panels (DA) & (DB) to both Lower side Panel (DC) & (DD) using hardware No. 6, 7, and 8 (x6). Open top lid (A) and position the three flame tamers (BC) as shown.
- Page 19 1. Insert grease tray bar-1(DI), and grease tray bar-2 (DJ) into the holes on inside of the cart assembly as shown. 2. Assemble the rear panel (DE) to the back of the burner box, using hardware No 1, 3, and 4 (x4). 3.
- Page 20 Remove the two screws and washers from the side burner valve bracket. Push the side burner valve stem and mount it by using the screws and washers which just removed, threading through the side burner control panel and the Bezel (EB). Push the knob (EC) onto the valve stem with the white line on the knob pointing upwards.
- Page 21 Attach the side burner igniter wire as shown. For Propane Model ONLY. Secure 20 lb propane tank onto the bottom shelf of the cart as shown, attach the regulator valve to 20 lb propane tank. Warning! Do not store the extra tank on the cart.
-
Page 22: Information On Natural Gas
I N F O R M A T I O N O N This model has a 12’ hose with a male coupling plug that will allow you to attach your barbecue to your residential gas line. N A T U R A L G A S M O D E L WE STRONGLY RECOMMEND CONTACTING A CERTIFIED GAS-TECHNICIAN TO INSTALL YOUR NATURAL GAS UNIT. - Page 23 D I S T R I B U T O R Trileaf Distribution Trifeuil Toronto, Canada M4S 2B8...