Table of Contents
Advertisement
Quick Links
SERIAL #:
3 - Y E A R L I M I T E D W A R R A N T Y
8 5 - 1 1 0 3 ( P R O P A N E ) ( G 4 1 3 0 1 )
8 5 - 1 0 0 3 - 6 ( N A T U R A L G A S ) ( G 4 1 3 0 2 )
Read and save this manual for future reference.
If pre-assembled, leave this manual with
unit for consumer's future reference.
For product inquiries, parts, warranty
and troubleshooting support, please call
1-877-707-5463
Barbecue 2000
S A F E U S E , C A R E A N D A S S E M B L Y M A N U A L
F O R Y O U R S A F E T Y
If You Smell Gas
1. Immediately turn off the flow
of gas to the unit.
2. Extinguish any open flame.
3. Open the lid of the unit.
4. If the odour does not stop quickly,
immediately call your gas supplier
or Fire Department for assistance.
F O R Y O U R S A F E T Y
1. Do not store or use gasoline or other
flammable vapours and liquids in the
vicinity of this or other appliance.
2. An LP Gas cylinder not connected for
use shall not be stored in the vicinity
of this or other appliance.
W A R N I N G
Failure to follow all of the manufacturer's
instructions could result in hazardous
fires, explosions, property damage,
or serious personal injury or even death.
W A R N I N G
Follow all leak check procedures carefully prior
to operation of barbecue, even if barbecue
was stored assembled. Do not try to light
this barbecue without reading the Lighting
Instructions section of this man ual.
T H I S B A R B E C U E I S F O R
O U T D O O R U S E O N L Y
Advertisement
Table of Contents
Subscribe to Our Youtube Channel
Related Manuals for Centro Barbecue 2000 Safe use, care and assembly manua
Summary of Contents for Centro Barbecue 2000 Safe use, care and assembly manua
- Page 1 SERIAL #: Barbecue 2000 S A F E U S E , C A R E A N D A S S E M B L Y M A N U A L F O R Y O U R S A F E T Y If You Smell Gas 1.
-
Page 2: Table Of Contents
Warranty ....ii This Centro Barbecue carries a three year limited warranty against defects in Installation Information ..1 manufacturing workmanship. -
Page 3: Installation Information
I N S T A L L A T I O N The installation of this appliance must be in accordance with all local codes, or in the absence of local codes: I N F O R M A T I O N Canadian installation must conform to the current national standards, which at this time •... -
Page 4: Transportation And
The Cylinder must also be equipped with: A shut-off valve with a correct cylinder valve outlet as specified in current standards. • Canada: CAN / CGA 1.6g-M97 Outdoor Gas Grilles. • a) A safety relief valve with direct connection to the vapour space of the cylinder. b) A collar to protect the tank shut-off valve. -
Page 5: Prior To Using The Grill
P R I O R T O U S I N G Do not use your barbecue until you have carefully read and fully understand all the information in this manual. Please ensure the following: Your barbecue is properly assembled. •... -
Page 6: Safety Hose And Regulator
S A F E T Y H O S E Propane Gas Models: Your barbecue is designed to operate on L.P. (Propane) gas at a pressure of 2.74 Kpa (11˝ water column). A regulator preset to this pressure is supplied A N D R E G U L A T O R with the barbecue and must be used. -
Page 7: Safety Leak Testing
To Reset The Gas Regulator Safety Device 1. Close the LP (propane) tank valve. 2. Turn all burner control knobs to the OFF position. 3. Disconnect the regulator from the LP tank. 4. Open the grill lid. 5. Open all of the control knobs to the high position. 6. -
Page 8: Lighting The Main Burners
L I G H T I N G Make Sure you have followed all the safety checks, procedures and instructions indicated in the previous section, before attempting to light the grill. T H E G R I L L Lighting The Main Burners 1. - Page 9 6. Confirm that the burner is properly lit. If the flame pattern is other than normal, consult the Troubleshooting Guide for corrective action. 7. Always preheat the Barbecue before starting to cook. Light all burners and adjust them to the HIGH position for 5-10 minutes. Before placing any food on the Barbecue, clean the cooking grids with a Porcelain cleaning brush.
-
Page 10: Parts List And
P A R T S L I S T I N G F O R Item No. Quantity Specification Part No. Top Lid Assembly 8 5 - 1 1 0 3 ( P R O P A N E ) Top Lid Weldment G413-0100-01 G 4 1 3 0 1... - Page 11 8 5 - 1 1 0 3 ( P R O P A N E ) G 4 1 3 0 1...
- Page 12 P A R T S L I S T I N G F O R Item No. Quantity Specification Part No. Top Lid Assembly 8 5 - 1 0 0 3 - 6 ( N A T U R A L G A S ) Top Lid Weldment G413-0100-01 G 4 1 3 0 2...
- Page 13 8 5 - 1 0 0 3 - 6 ( N A T U R A L G A S ) G 4 1 3 0 2...
-
Page 14: Assembly Instructions
A S S E M B L Y I N S T R U C T I O N S Hardware Pack List Description Part Number Quantity Tools Needed for Assembly 1/4” x 38 mm Screw 20120-13038-250 1/4” x 13 mm Screw 20120-13013-250 #2 Phillips ®... - Page 15 Fig. 1 Attach two front casters (EH) and two back casters with lock (EG) to the bottom shelf (EF) by using the provided wrench hardware #11. Fig. 2 Assemble the cart left side panel (EA) and cart right side panel (EB) to the bottom shelf (EF) using hardware #2, #3, #4 and #5 (x6).
- Page 16 Fig. 4 Assemble the upper brace (CH) below the control panel (CE) as shown using hardware #6,#7 and #8 (x4). Remove the screws and nuts from the top lid handle (AB), then assemble the top lid handle (AB) to the top lid (AC) by using the hardware which was just removed.
- Page 17 Fig. 7 Insert grease tray left and right rail (CJ) & (CK) into the holes at the inside of the cart assembly as shown. Insert the tank heat shield (CI) into the holes in the upper rail. Assemble the upper back panel (CL) to the back of the burner box by using hardware #1, #3 and #4 (x4).
- Page 18 Unscrew the igniter cap and place AA battery which is provided into igniter (CD) with positive end (+) facing outward. Screw igniter cap onto igniter as shown. Fig. 10 Fig. 11 For propane model only Secure 20lb propane tank onto the bottom shelf of the cart as shown, attach the regulator valve to 20lb propane tank.
-
Page 19: Information On
I N F O R M A T I O N O N This model has a 12’ hose with a male coupling plug that will allow you to attach your barbecue to your residential gas line. N A T U R A L G A S M O D E L WE STRONGLY RECOMMEND CONTACTING A CERTIFIED GAS-TECHNICIAN TO INSTALL YOUR NATURAL GAS UNIT. - Page 20 D I S T R I B U T O R Trileaf Distribution Trifeuil Toronto, Canada M4S 2B8...
Need help?
Do you have a question about the Barbecue 2000 Safe use, care and assembly manua and is the answer not in the manual?
Questions and answers