Table of Contents
Advertisement
Quick Links
Washer-Extractor
Pocket Hardmount
Instructions for Operating the
WE-4 and WE-5 Microcomputers
COLD /
HOT /
LOW
HIGH
WASH /
HEAT /
FLUSH
RINSE
SOAK
MEDIUM
PAUSE
SPEED
DRAIN
CLEAR
STOP
www.comlaundry.com
UW50P4
WARM /
DISPLAY
TEMP. /
CYCLE
OVER
ADD
SUPPLY
CYCLE
NUMBER /
ADVANCE
HIGH
ERASE
CYCLE
NUMBER
SPEED
ENTER
BUZZER
NO
START
REVERSE
PHM542N
Part No. F232161
September 2002
Advertisement
Table of Contents
Related Manuals for Alliance Laundry Systems POCKET HARDMOUNT UW50P4
Summary of Contents for Alliance Laundry Systems POCKET HARDMOUNT UW50P4
- Page 1 Washer-Extractor WE-4 and WE-5 Microcomputers Pocket Hardmount Instructions for Operating the COLD / HOT / WARM / DISPLAY TEMP. / CYCLE HIGH OVER WASH / HEAT / SUPPLY CYCLE NUMBER / ADVANCE FLUSH RINSE SOAK MEDIUM HIGH ERASE CYCLE NUMBER PAUSE SPEED SPEED...
-
Page 3: Table Of Contents
All rights reserved. No part of the contents of this book may be reproduced or transmitted in any form or by any means without the expressed written consent of the publisher. F232161 © Copyright, Alliance Laundry Systems LLC – DO NOT COPY or TRANSMIT Introduction... Nameplate Location... - Page 4 Notes © Copyright, Alliance Laundry Systems LLC – DO NOT COPY or TRANSMIT F232161...
-
Page 5: Nameplate Location
Always provide the machine’s serial number and model number when ordering parts or when seeking technical assistance. Nameplate © Copyright, Alliance Laundry Systems LLC – DO NOT COPY or TRANSMIT F232161 Introduction Replacement Parts If literature or replacement parts are required, contact... - Page 6 Notes © Copyright, Alliance Laundry Systems LLC – DO NOT COPY or TRANSMIT F232161...
-
Page 7: Safety Information
NOTE: The word “NOTE” is used to communicate installation, operation, maintenance or servicing information that is important but not hazard related. © Copyright, Alliance Laundry Systems LLC – DO NOT COPY or TRANSMIT F232161 Safety Information Important Safety Instructions To reduce the risk of fire, electric shock,... - Page 8 If this occurs, have washer checked by a qualified service person. © Copyright, Alliance Laundry Systems LLC – DO NOT COPY or TRANSMIT 19. Replace worn power cords and/or loose plugs. 20. Be sure water connections have a shut-off valve and that fill hose connections are tight.
-
Page 9: Operation
Hot Spray Valve On Cold Spray Valve On Hot Fill Valve On © Copyright, Alliance Laundry Systems LLC – DO NOT COPY or TRANSMIT F232161 Operation Theory of Operation NOTE: When power has been turned off from the machine and then reapplied, the display will read “WAIT”... -
Page 10: Start-Up
The machine should not start or run if the door is not both closed and locked. © Copyright, Alliance Laundry Systems LLC – DO NOT COPY or TRANSMIT Select Cycle Find the cycle number (cycle numbers must be two- digit numbers) of the desired wash cycle from the cycle code list provided. -
Page 11: Test Cycle
It is possible to skip to the next step in the cycle except a drain step. To do so, press the ADVANCE key. Drain procedures must be allowed to complete. © Copyright, Alliance Laundry Systems LLC – DO NOT COPY or TRANSMIT F232161 LED Display When display shows letters and/or numbers with or without the beeper, refer to Table 1. - Page 12 Minutes (used when programming time) Medium Speed Spin NOTE: For further explanation of problem indication displays, consult Test Procedure section of this manual. © Copyright, Alliance Laundry Systems LLC – DO NOT COPY or TRANSMIT Display Interpretations Display Soak Supply #1 (Soap/Break)
-
Page 13: Test Procedure
Test the keypad, first with the keyed mode switch in the Run position. A beep tone should sound as each key is pressed. © Copyright, Alliance Laundry Systems LLC – DO NOT COPY or TRANSMIT F232161 NOTE: Keys should be pressed at their centers and only hard enough to activate them. - Page 14 Check for obstructions in air system to level switches. c. Check for slow drain. © Copyright, Alliance Laundry Systems LLC – DO NOT COPY or TRANSMIT NOTE: Sufficient time for filling and draining must be allowed when a program is written into the computer.
-
Page 15: Motor Thermal Overload Indicator
Failure to take corrective action when the indicator lamp is lit will ultimately result in damage to the motor(s). © Copyright, Alliance Laundry Systems LLC – DO NOT COPY or TRANSMIT F232161 This machine must be installed, adjusted, and serviced by qualified electrical... - Page 16 Notes © Copyright, Alliance Laundry Systems LLC – DO NOT COPY or TRANSMIT F232161...