Changing Engine Oil And Oil Filter - MOTO GUZZI BREVA V1100 Manual

CHANGING ENGINE OIL AND OIL
FILTER
CAUTION
Changing engine oil and engine oil filter
can prove difficult; these operations are
best left to experienced mechanics.
If necessary, contact your Moto Guzzi
Authorised Dealer.
If you wish to perform these operations
yourself, follow these instructions.
Carefully read page 42 (ENGINE OIL)
and page 57 (MAINTENANCE).
NOTE
Halve maintenance intervals if
you are riding in rainy or dusty conditions,
on rough road surfaces or when the vehicle
is used in competitions.
Periodically check engine oil level, change
the oil every 10000 km (6250 mi), see page
6 2 ( CH E CK I N G A N D T O P P I NG U P
ENGINE OIL LEVEL).
To change oil:
NOTE
Warm oil is more fluid and will
drain out more easily and completely; ideal
temperature is reached after engine has
been running for about 20 minutes.
1
CAUTION
Oil becomes very hot when engine is
warmed up; beware of scalds during the
procedure described below.
Place a container with more than 4000
u
cu. cm. capacity under the drain plug (1).
Unscrew and remove the drain plug (1).
u
Unscrew and remove the filler plug (2).
u
Drain the oil into the container; allow
u
several minutes for oil to drain out
completely.
Check the sealing washers of the drain
u
plug (1) and replace them if needed.
Remove any metal debris collected by
u
the drain plug (1) magnet.
Tighten the drain plug (1).
u
Drain plugs (1) tightening torque: 12 Nm
(1.2 kgm).
2
CAUTION
D o n o t d i s p o s e o f o i l i n t h e
environment. Dispose of engine oil -
stored in a sealed container - through
the nearest waste oil reclamation firm or
through the supplier.
CHANGING THE ENGINE OIL FILTER
NOTE
Halve maintenance intervals if
you are riding in rainy or dusty conditions,
or on rough road surfaces.
Change the engine oil filter every 10000
km (6250 mi) or anyway each time you
change the engine oil.
use and maintenance Breva
63