Page 3
For service, contact your sales representative or call: EnerSys EMEA EnerSys World Headquarters EH Europe GmbH 2366 Bernville Road Baarerstrasse 18 Reading, PA 19605, USA...
Page 4
RATING DATA & SAFETY Rail engine starting flooded, flat plate, Pb-1.7%Sb/Pb-1.7%Sb 12V monoblocs. Rating Data 1. Nominal capacity C See type plate 2. Nominal voltage: See type plate 3. Discharge current See type plate 4. Nominal specific gravity (S.G.) of 1.29 kg/l electrolyte 5.
Page 5
Ignoring the operating instructions, repair with non-original parts, and disconnection of the easy control will render the warranty void. All the failures, malfunctions, or defaults of the battery, the charger, or any other accessories, must be reported to EnerSys Service.
Page 6
OPERATION Operation The nominal operating battery temperature is 0°C. The optimum lifetime of the battery 25°C. Higher temperatures shorten the life of the depends on the operating conditions (moderate battery, lower temperatures reduce the available temperature and discharges equal to or lower capacity.
Page 7
OPERATION Charging (cont.) When charging, proper provision must be made should only begin if the electrolyte temperature for venting the charging gases. Battery container is below 45°C. The electrolyte temperature of lids and the covers of battery compartments the battery should be at least +10°C before must be opened or removed.
Page 8
MAINTENANCE Desulphation Charge Electrolyte Should be carried out after a very deep discharge The electrolyte nominal S.G. is 1.29 kg/l at 25°C when of the battery (> 80% C5) when the charger does in fully charged condition. According to temperature, not start the recharge due to an over-discharge S.G.
Page 9
STORAGE Storage and Transportation Batteries must always be stored and transported The storage time is to be considered within the securely in the vertical position in order to avoid battery life expectancy. To ensure the battery any electrolyte leakage. Store the battery in a is always ready for use, a choice of charging fully charged condition in a dry, clean, and methods can be made:...
Need help?
Do you have a question about the HAWKER PerfectRail DS and is the answer not in the manual?
Questions and answers