Checking The Engine Oil Level And Topping Up - APRILIA SCARABEO 125 - 2003 Manual

1
2
CHECKING THE ENGINE OIL
LEVEL AND TOPPING UP
Carefully read p. 23 (LUBRICANTS),
p . 3 7 ( M A I N T E N A N C E ) a n d p . 6 9
(LUBRICANT CHART).
CHECKING
NOTE
Position the vehicle on firm and
flat ground.
◆
Position the vehicle on the centre stand.
WARNING
The engine and the components of the
exhaust system become very hot and
remain hot for some time after the
engine has b een stop ped. Before
handling these components, wear
insulating gloves or wait until the
engine and the exhaust system have
cooled down.
3
◆
Stop the engine and let it cool down, in
order to allow the oil to flow into the oil
pan and to cool down.
NOTE
Failure to perform the operations
described above may result in the incorrect
measurement of the engine oil level.
◆
Release the three screws (1) securing oil
inspection cover (2).
◆
Remove the oil inspection cover (2) from
vehicle left-hand side.
◆
Unscrew and extract the plug/dipstick
(1).
◆
Clean the part in contact with the oil with
a clean cloth.
◆
Tighten the plug/dipstick (3) completely,
screwing it into the filling hole (4).
◆
Withdraw the plug/dipstick (3) again and
read the oil level on the dipstick itself:
MAX = maximum level;
MIN = minimum level.
The difference between "MAX" and
"MIN" is about 200 cm
4
◆
The level is correct if the oil reaches
approx. the "MAX" mark on the dipstick.
CAUTION
Never exceed the "MAX" mark, nor
leave the oil below the "MIN" mark, in
order to avoid serious damage to the
engine.
◆
If necessary, provide for topping up.
TOPPING UP
◆
Pour a small quantity of oil in the filling
hole (4) and wait about one minute, so
that the oil flows into the oil pan.
◆
Check the oil level and top up if
necessary.
◆
Top up by adding small quantities of oil,
until reaching the prescribed level.
◆
At the end of the operation, screw and
tighten the plug/dipstick (3).
WARNING
Do not use the vehicle with insufficient
lubrication or with contaminated or
unsuitable lubricants, since this would
cause early wear of the moving parts
and may also cause irreparable failures.
use and maintenance Scarabeo 125 - Scarabeo 200
3
.
41