Table of Contents
Advertisement
Quick Links
INSTRUCTIONS FOR USE
WARNING
Before departure, always carry out a pre-
liminary checking of the vehicle, to make
sure that it functions correctly and safely,
see the following table PRELIMINARY
CHECKING OPERATIONS.
The non-performance of these checking
operations can cause severe personal
injuries or damages to the vehicle.
Do not hesitate to consult your aprilia
Official Dealer in case there is something
you do not understand about the func-
tioning of some controls or in case you
suspect or discover some irregularities.
It does not take long to carry out a check-
up and this operation ensures you much
more safety.
PRELIMINARY CHECKING OPERATIONS
Component
Check the functioning, the fluid level and make sure there
Disc brakes
are no leaks. Check the wear of the pads.
Top up, if necessary.
Check the functioning, the idle stroke and control lever
Rear drum brake
condition. Adjust the play, if necessary.
100
Make sure that it works smoothly and that it is possible to
Accelerator
open and close it completely, in all steering positions.
If necessary, adjust and/or lubricate it.
Check and/or top up, if necessary.
Mixer oil
Check the tyre surface, the inflation pressure, wear and
Wheel / tyres
tear and any damage.
Remove any foreign matter that may be stuck in the tread
grooves.
Make sure that they work smoothly.
Brake levers
If necessary, lubricate the articulations.
Make sure that the steering rotates smoothly, without any
Steering
clearance or slackening.
Make sure that they work smoothly and that the spring
Stand
tension brings it back to its normal position. If necessary,
lubricate joints and hinges.
Fastening elements
Make sure that the fastening elements are not loose.
If necessary, adjust or tighten them.
Check the fuel level and top up, if necessary.
Fuel tank
Make sure there are no leaks or occlusions in the circuit.
Lights, warning lights,
Check the proper functioning of all the devices.
injection warning light
Change the bulbs or intervene in case of failure.
, horn and electric
devices
Injection pump
Check operation.
Check
use and maintenance Scarabeo 50
Page
31, 32, 61
33, 62
70
28
34
–
63
68
–
27, 83
72 – 81
18
- Scarabeo 100 4T
37
Advertisement
Table of Contents
Subscribe to Our Youtube Channel
Related Manuals for APRILIA SCARABEO 100 4T - 06-2001 PART7
Summary of Contents for APRILIA SCARABEO 100 4T - 06-2001 PART7
- Page 1 If necessary, lubricate joints and hinges. injuries or damages to the vehicle. Do not hesitate to consult your aprilia Fastening elements Make sure that the fastening elements are not loose. –...
-
Page 2: Electric Starting
NOTE STARTING After a long period of inactivity, carry ELECTRIC STARTING out the operations described at page 40 Position the vehicle on the centre stand, WARNING (STARTING AFTER A LONG PERIOD OF on a solid and level surface. INACTIVITY). Exhaust gases contain carbon monoxide, Make sure that the light switch (1) is in which is extremely noxious if inhaled. -
Page 3: Kick Start
Press the start push button “ ” (5), rotate Let the kick starter go back to home posi- stop the vehicle and contact an aprilia the throttle twistgrip by 1/8 of its turn (see tion (6). Official Dealer. -
Page 4: Starting With Cold Engine
STARTING WITH FLOODED ENGINE If the engine starts. Before reinstalling it: Release the throttle grip (7). NOTE Put a clean cloth on the cylinder, If the starting is not carried out properly or if If the idling is unstable, twist the throttle near the spark plug seat, in order to protect there is too much fuel in the intake ducts and grip (7) slightly and frequently. -
Page 5: Departure And Drive
DEPARTURE AND DRIVE To leave, release the brake lever and the WARNING vehicle will start moving. NOTE Before departure, carefully read the If you drive with a passenger, instruct “safe drive” chapter, see page 5 (SAFE him/her so that he / she does not create DRIVE). - Page 6 WARNING WARNING WARNING Before beginning to turn, slow down or When riding in conditions of poor visibil- If you have to brake, close the throttle and brake driving at moderate and constant ity, switch on the high beam lights to im- put on both brakes in order to obtain uni- speed or accelerating slightly;...
- Page 7 WARNING WARNING WARNING Always use the direction indicators in If the mixer oil reserve warning light “ ” Pay the utmost attention to any obstacle time when you intend to change lane or comes on during the normal functioning or variation of the road surface. direction, avoiding sharp and dangerous of the engine, this means that the mixer Uneven roads, rails, manhole covers, in-...
- Page 8 RUNNING-IN For the first 500 km (312 mi), keep to the following indications: WARNING 0-100 km (0-62 mi) During the first 100 km (62 mi) put on the After the first 500 km (312 mi), carry out brakes with caution, avoiding sharp and the checking operations indicated in the prolonged brakings.
-
Page 9: Positioning The Vehicle On The Centre Stand)
STOPPING PARKING Rotate the key (1) and move the ignition switch (2) to position “ ”. WARNING WARNING Position the vehicle on the stand, see page If possible, avoid stopping abruptly, slow- Park the vehicle on firm and flat ground, 46 (POSITIONING THE VEHICLE ON THE ing down suddenly and braking at the last to prevent it from falling down. -
Page 10: Suggestions To Prevent Theft
Grasp the left handgrip and the rear han- garage or a protected place. NAME: ............dle (1). Push down the stand lever (2). If possible, use the appropriate aprilia ADDRESS: ..........“Body-Guard” armored cable , or an ad- ditional anti-theft device. - Page 11 Ask your aprilia Official Dealer to test the tion block, wait until the engine and the vehicle on the road after a repair or periodic...
-
Page 12: Regular Service Intervals Chart
Every 8000 km OPERATIONS TO BE CARRIED OUT BY Components [500 km (2500 mi) (5000 mi) THE aprilia Official Dealer (WHICH CAN (312 mi)] or 12 months or 24 months BE CARRIED OUT EVEN BY THE USER) Battery / electrolyte level... - Page 13 OPERATIONS TO BE CARRIED OUT BY THE aprilia Official Dealer After running-in Every 4000 km Every 8000 km Components [500 km (2500 mi) (5000 mi) 1 = check and clean, adjust, lubricate or (312 mi)] or 12 months or 24 months change, if necessary;...
- Page 14 OPERATIONS TO BE CARRIED OUT BY THE aprilia Official Dealer After running-in Every 4000 km Every 8000 km Components [500 km (2500 mi) (5000 mi) 1 = check and clean, adjust, lubricate or (312 mi)] or 12 months or 24 months change, if necessary;...
- Page 15 REGULAR SERVICE INTERVALS CHART OPERATIONS TO BE CARRIED OUT BY After running-in Every 4000 km Every 8000 km THE aprilia Official Dealer (WHICH CAN Components (5000 mi) [1000 km (2500 mi) BE CARRIED OUT EVEN BY THE USER) (625 mi)]...
- Page 16 OPERATIONS TO BE CARRIED OUT BY THE aprilia Official Dealer After running-in Every 4000 km Every 8000 km Components [1000 km (2500 mi) (5000 mi) 1 = check and clean, adjust, lubricate or (625 mi)] or 12 months or 24 months change, if necessary;...
- Page 17 After running-in Every 4000 km Every 8000 km Components [1000 km (2500 mi) (5000 mi) 1 = check and clean, adjust, lubricate or (625 mi)] or 12 months or 24 months change, if necessary; 2 = clean; Wheels, tyres and inflating pressures 3 = change;...
-
Page 18: Identification Data
IDENTIFICATION DATA FRAME NUMBER The frame number is stamped on the cen- It is a good rule to write down the frame and tral tube of the frame. To be able to read it, engine numbers in the space provided in this remove the cover (1). -
Page 19: Air Cleaner
AIR CLEANER REMOVAL NOTE If the cleaner is clogged, remove Carefully read page 47 (MAINTENANCE). Position the vehicle on the centre stand, the filtering element (4) and replace it. on a solid and level surface see page 46 (POSITIONING THE VEHICLE ON THE Check the conditions of the air cleaner CENTRE STAND). - Page 20 AIR CLEANER REMOVAL CLEANING Carefully read page 47 (MAINTENANCE). Position the vehicle on the centre stand, WARNING on a solid and level surface, see page 46 Do not use petrol or inflammable solvents (POSITIONING THE VEHICLE ON THE Check the conditions of the air cleaner and to wash the filtering element, in order to CENTRE STAND).
Need help?
Do you have a question about the SCARABEO 100 4T - 06-2001 PART7 and is the answer not in the manual?
Questions and answers