Masonry And Insulation; Installing The Chimney And Steam Vents; Lws Listed Chimney; Single Wall Chimney (Non-Listed) - Lapierre VISION User Manual

SECTION 4 Installation and component assembly (continued)
• Evaporator LEFT-RIGHT level.
a. Using a level, adjust the left and right legs of the front section of the evaporator to bring it perfectly level.
b. Repeat step (a) for the rear section of the evaporator.
• Evaporator FRONT-CENTRE-REAR level.
a. From the front of the left side, adjust the front centre section (1) so that it is level.
b. In the same way, extend the levelling toward the centre-rear section (2) by adjusting the rear leg with the
level of the front-centre section.
c. Check if the rear section is still on the left-right level.
- If not, adjust the rear leg on the opposite side to bring this section back to level.
d. Repeat steps (a) (b) and (c) for the right side of the evaporator.
• Check all left-right and front-centre-rear levels, and adjust as necessary until the evaporator is perfectly level.
You may need to repeat this step a few times.
Place the pans in the evaporator.
To do this, refer to Section 4.4, Pan installation.
• Fill the pans with water to check if the evaporator is still level.
• Your evaporator is considered level if it meets the following tolerance:
- measure the height from the water surface to the rim in each corner of the pan,
- the difference between the highest and lowest height must be less than 1/8 in. (4 mm),
- otherwise, the previous levelling steps must be repeated.

4.2 MASONRY AND INSULATION

If you have ordered a masonry and insulation kit from LAPIERRE EQUIPMENT, refer to Appendix A: Installation
instructions for insulating materials for the procedures and installation steps.

4.3 INSTALLING THE CHIMNEY AND STEAM VENTS

4.3.1

LWS listed chimney

See the user manual for the listed chimney. Copies of the manual are located with your evaporator documents
and in the rain cap box.
4.3.2

Single wall chimney (non-listed)

See Appendix J for the installation of the single-wall chimney.
4.3.3

Steam vents

See Appendix K for the installation of the steam vents.
Lapierre Equipment | | USER MANUAL | Version 03 - March 2023
VISION EVAPORATOR
11