Section 9 − Parts List; Recommended Spare Parts - Miller PipePro Series Owner's Manual

Trouble
Engine hard to start in cold weather
(continued).
Engine suddenly stops.
Engine slowly stopped and cannot be
restarted.
Battery discharges between uses.
Engine idles, but does not come up to
weld speed.
Engine does not run at idle speed.
Engine uses oil during run-in period;
wetstacking occurs.

9-1. Recommended Spare Parts

Dia. Part
Mkgs.
. . . . . . . . . . . F1 . . . . . 085874
. . . . . . . . . . . . . . . . . . . . 244290
. . . . . . . . . . . . . . . . . . . . 242883
. . . . . . . . . . . . . . . . . . . . 252782
. . . . . . . . . . . . . . . . . . . . 252781
. . . . . . . . . . . . . . . . . . . . 213858
. . . . . . . . . . . . . . . . . . . . 242882
. . . . . . . . . . . . . . . . . . . . 197676
. . . . . . . . . . . . . . . . . . ♦197679
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
♦Optional
To maintain the factory original performance of your equipment, use only Manufacturer's Suggested
Replacement Parts. Model and serial number required when ordering parts from your local distributor.
.
Complete Parts List is available at www.MillerWelds.com
Have Factory Authorized Service Agent check Preheat switch S4, control relay CR3, and the glow
plug.
Check oil and coolant levels. Automatic shutdown system stops engine if oil pressure is too low or coolant
temperature is too high (see Sections 5-6 and 5-7).
Check fuel/hour meter for indication of shutdown.
Reset supplementary protector CB2 and/or clear fault causing circuit breaker CB1 to trip (see Section
8-10). Have Factory Authorized Service Agent check engine alternator, engine harness, fuel solenoid
FS1, and the fuel pump.
Have Factory Authorized Service Agent check Engine Control switch S1, control relay CR1, inte-
grated rectifier SR2, fuel solenoid FS1, and the fuel pump.
See engine manual.
Check fuel level.
Check fuel/hour meter for indication of shutdown.
Check engine air and fuel filters (see Sections 8-7 and 8-11).
See engine manual.
Turn Engine Control switch off when unit is not running.
Clean top of battery with baking soda and water solution; rinse with clear water.
Recharge or replace battery if necessary. It may be necessary to remove oil filter to replace battery.
Periodically recharge battery (approximately every 3 months).
Have engine Factory Authorized Service Agent check engine speed control system.
Have engine Factory Authorized Service Agent check engine speed control system.
Dry engine according to run-in procedure (see Section 11).
SECTION 9 − PARTS LIST
No.
. . Fuse, Mintr Cer Slo−blo 10. Amp 250 Volt
. . Brushholder Assembly, Generator w/Leads
. . Belt, Alternator (Mitsubishi)
. . Filter Kit, Mitsubishi (S4l2) (Includes)
. . Filter, Fuel Spin−on
. . Filter, Fuel In−line 5/16x5/16 Mic 125 −175
. . Filter, Lube Oil
. . Element, Air Cleaner
. . Element, Air Cleaner Safety
Battery, Stor 12v 500 Crk 75 Rsv Gp 55
Remedy
Description
. . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . .
OM-262506 Page 55
Quantity
1
1
1
1
1
1
1
1
1
1