Dispenser Troubleshooting - Cornelius IntelliCarb Cold Beverage Dispenser Training Manual

IntelliCarb Training Manual
D T
ISPENSER ROUBLESHOOTING
Should your unit fail to operate properly, check that there is power to the unit and that the hopper
contains ice. If the unit does not dispense, check the following chart under the appropriate symptoms to
aid in locating the defect.
Trouble
BLOWN FUSE OR CIRCUIT
BREAKER.
GATE DOES NOT OPEN.
AGITATOR DOES NOT
TURN.
GATE DOES NOT OPEN OR
IS SLUGGISH. AGITATOR
TURNS.
ICE DISPENSES CONTINU-
OUSLY.
SLUSHY ICE. WATER IN
HOPPER.
BEVERAGES DO NOT DIS-
PENSE
BEVERAGES TOO SWEET
Publication Number: TP01071
Probable Cause
A. Short circuit in wiring
B. Inoperable gate solenoid.
C. Inoperable agitator motor.
A. No power.
B. Bent depressor plate (does not
actuate switch).
C. Inoperable dispensing switch.
A. Inoperable gate solenoid.
B. Excessive pressure against gate
slide.
C. Inoperable rectifier.
A. Stuck or bent depressor plate
(does not release switch).
B. Inoperable dispensing switch.
C. Improper switch installation.
A. Blocked drain.
B. Unit not sitting level.
C. Poor ice quality due to water qual-
ity or icemaker problems.
D. Improper use of flaked ice.
A. No 24 volts power to faucets.
B. No CO pressure.
2
A. Carbonator not operating.
- 38 -
Remedy
A. Repair wiring.
B. Replace gate solenoid.
C. Replace agitator motor.
A. Restore power.
B. Replace depressor plate.
C. Replace dispensing switch.
A. Replace gate solenoid.
B. Adjust gate slide.
C. Replace rectifier.
A. Replace depressor plate.
B. Replace dispensing switch.
C. Make sure switch is installed
properly.
A. Unplug drain.
B. Level the unit.
C. Correct water quality or repair ice-
maker.
D. Call Service Person.
A. Restore 24 volt power to faucets.
B. Restore CO pressure.
2
A. Repair carbonator.
© 2004, IMI Cornelius Inc.