Index Customer Care Warranty Consumer Information Anti-tip Device Important Safety Information Features of Your Range Installation Instructions Door Handle Installation Cooktop Burner Grills Installation Oven Rack Rail Installation Electrical Gas Supply Pressure Regulator Gas Shut-off Valve (not included) Product Dimensions and Cabinets Exhaust Hood Installation Gas Conversion Operation Cooktop Operation...
Thank you for purchasing a FORNO product. Please read the entire instruction manual before operating your new appliance for the first time. Whether you are an occasional user or an expert , it will be beneficial to familiarize yourself with the safety practices, features, operation and care recommendations of your appliance.
30-Day Cosmetic Warranty The Purchaser must inspect the product at the time of delivery. Forno warrants that the Product is free from manufacturing defects in materials and workmanship for a period of thirty (30) days from date of the original retail purchase of the Product.
Page 5
DAMAGES CAUSED BY THE USE, MISUSE OR INABILITY TO USE THIS PRODUCT, REGARDLESS OF THE LEGAL THEORY ON WHICH THE CLAIM IS BASED, AND EVEN IF FORNO HAS BEEN ADVISED OF THE POSSIBILITY OF SUCH DAMAGES. NOR SHALL RECOVERY OF ANY KIND AGAINST FORNO BE GREATER IN AMOUNT THAN THE PURCHASE PRICE OF THE PRODUCT SOLD BY FORNO AND CAUSING THE ALLEGED DAMAGE.WITHOUT PREJUDICE TO THE FOREGOING, PURCHASER ASSUMES ALL RISK AND...
Consumer information Range Safety Your safety and the safety of others are very important. We have provided many important safety messages in this manual and on your appliance. Always read and obey all safety messages. This is a safety alert symbol. It will alert you to potential personal or property safety hazards. Obey all safety messages to avoid any property damage, personal injury or death.
Make sure the anti-tip bracket is installed. Range back panel Slide range forward. Make sure the anti-tip bracket is securely attached to the wall behind the range. Anti-tip bracket WARNING This product can expose you to chemicals including carbon monoxide, which is known to the State of California to cause developmental harm.
Page 8
3. Any adjustment and service should be performed only by a qualified gas range installer or service technician. Do not attempt to repair or replace any part of your range unless it is specifically recommended in this manual. 4. Your range is shipped from the factory set for use with natural gas or propane (LP) gas. It can be converted for use with either.
Page 9
WARNING DO NOT carry or lift the cooking range by the oven door handle or the control panel! CORRECT INCORRECT INCORRET WARNING Never pour cold water to hot surfaces in a hot oven. The steam created could cause serious burns or scalding and the sudden change in temperature can damage the enamel in the oven. WARNING Cook food thoroughly to help protect against foodborne illness.
Page 10
WARNING COOKTOP SAFETY INSTRUCTIONS Never leave the surface burners unattended at medium or high heat settings. Foods, especially oily foods, may ignite resulting in fire that could spread to surrounding cabinets. Never leave oil unattended while frying. If allowed to heat beyond its smoking point, oil may ignite resulting in fire that may spread to surrounding cabinets.
Features of Your Range 8 burners 6 burners 5 burners Oven Vents Cooktop Burner Grills Griddle (on some models) LED Light Switch Control Panel Oven Lights Switch Rotisserie Temperature Control Knob Broil/Oven Control Knob Kick Panel Leveling System(Oven legs) Not all features are on all models.Appearance may vary. Wok Support...
Installation Instructions Before using your range 1. Remove all packaging material. 2. Check to make sure you have all of the accessories listed below FFSGS6387-30 15 sets FFSGS6387-36 18 sets 0.9, 0.46 LPG injector FFSGS6387-48 24 sets Anti-tip bracket and screws...
YOU NEED TOOLS FOR INSTALLATION. (not supplied with the range) Tape measure Screwdriver Wrench Socket wrench Allen key &Pencil Protective Adjustable Hammer Adjustable Drill gloves wrench pliers Door handle installations The door handle is not pre-installed. Follow the illustrations below to install the door handle quickly and easily. Align the handle with the screw on the door.
If there is any doubt as to whether the power supply has the correct polarity or grounded, have it checked by a qualified electrician. ELECTRICAL REQUIREMENTS Electrical Supply FFSGS6387-30 3600W Grounded, 240 VAC, 60Hz FFSGS6387-36 3600W Grounded, 240 VAC, 60Hz...
CAUTION Label all wires prior to disconnection when servicing controls. Wiring errors can cause improper and dangerous operation. Verify proper operation after servicing. Grounding The power cord is equipped with a four-prong (grounding) plug which mates with a standard four-prong grounding wall receptacle to minimize the possibility of electrical shock hazard from the range.
Electric Power Supply Requirements Recommended power outlet area 46" (1169) 28" (715) 34" (866) For reference only, please refer to the real object. Pressure Regulator Since service pressure may fluctuate with local demand, every gas cooking range must be equipped with a pressure regulator on the incoming service line for safe and efficient operation.
Product Dimensions and Cabinets Model#: FFSGS6387-30 Model#: FFSGS6387-36 Model#: FFSGS6387-48 This range may be installed directly adjacent to existing countertop-height cabinets (36" or 91.5 cm from the floor). To achieve the best look, the cooktop should be level with the cabinet countertop. This can be...
Page 18
1/ Remove the two screws in the back of the range. 2/ Install the wall-against mat instead.
Page 19
Model#: FFSGS6387-30 Min. 7’’ 4/5 (199mm) Min. 5’’ 3/5 (142mm) 5’’ 4/5 15’’ 1/5 3’’ (77mm) 28’’ (715mm) (149mm) (387mm) Max. 9’’ ½ (242mm) Max. 7’’ 3/10 (185mm) Model#: FFSGS6387-36 Min. 7’’ 4/5 (199mm) Min. 5’’ 3/5 (142mm) 5’’ 4/5 9’’...
Page 20
Model#: FFSGS6387-48 Min. 7’’ 4/5 (199mm) Min. 5’’ 3/5 (142mm) 5’’ 4/5 41’’ 9/10 46’’ 3’’ (77mm) (149mm) (1064mm) (1169mm) Max. 9’’ ½ (242mm) Max. 7’’ 3/10 (185mm) Maximum depth for cabinets above countertop Minimum to cabinets on either sides of the range Opening width Min.
Exhaust Hood Installation The bottom of the hood should be 30" min. to 36" above the countertop. This would typically result in the bottom of the hood being 66" to 72" above the floor. These dimensions provide safe and efficient operation of the hood. After Installation: 1.
Page 22
IMPORTANT: Each injector has a number indicating its flow diameter printed on the body. Consult the table below for matching nozzles with cooktop burners. COOKTOP BURNERS ORIFICE FOR NATURAL GAS (NG) A. 20,000BTU & LIQUID PROPANE (LP) 1.38 x 2 (OUTER) 0.75 x 1 (CENTER) 0.9 x 2 (OUTER) 0.46 x 1 (CENTER) Model:FFSGS6387-30...
Page 23
Model:FFSGS6387-36 Model:FFSGS6387-48 IMPORTANT: Keep the injectors removed from the range for future use.
Page 24
STEP 3: Gas Valve a. Remove control knobs. b. Using a flat screwdriver, adjust main burner bypass jets toward to 1/4 circle for LP until the flame is normal. For 20,000btu burners, please refer to fig.1, which is in the left side of valve axis. PLEASE NOTE: If the bypass jets screw is tighten too much, the igniter will go ON when burner is set to minimum because the gas outlet is too low.
Anti-Tip Bracket To prevent the range from tipping forward, the anti-tip bracket must be installed. Refer to the section of ANTI-TIP DEVICE. Gas Supply Connection All connections to the gas piping must be wrench-tightened. Do not overtighten or allow pipes to turn when tightening.
Heat Settings: Ignites the burners. Simmer Melting small quantities, steaming rice, warming food, melting chocolate or butter. Melting large quantities. Low-Medium Low-temperature frying, simmering large quantities, heating milk, cream sauces, gravies. Medium Sauting and browning, braising, pan-frying, maintaining slow boil on large quantities. Medium-Hi High-temperature frying, pan boiling, maintaining slow boil on large quantities.
Start low and don't overheat! - You might get the urge to turn your burners up to full blast the first time you use the FORNO grill/griddle, but don't! Burners only need to be set to 1/3 to 1/2 power to heat the grill/ griddle to over 500 degrees.
Oven Roasting Use the screws on Insert the smooth side of the rotisserie Hang the side with sink limit of the the rotisserie rod to rod into the rotisserie motor on the rotisserie rod to the hook on the adjust the distance right side.
ELECTRIC OVEN FUNCTIONS Various oven functions allow the user to operate flexibly to achieve different cooking result. (Temperature control knob) (Oven function knob) (for 18” oven only) CONV. HIGH BAKE Two heat two elements and fan working together under this function - top and bottom, for faster heat-up and shorter cooking times at lower temperatures.
If it's the case, remove them from, clean them thouroughly and remove any excess of water. Forno is not responsible for any maintenance related issues. Using a damp cloth, wipe with a mild detergent or spray degreaser; rinse and Control knobs dry.
Oven interior Use mild abrasive cleaners, spray degreasers. Use a razor blade to gently lift baked on foods from oven cavity and window. For stubborn stains, spray with a mild abrasive cleaner or spray degreaser. Wash the entire oven cavity with soap and water to remove all cleaning chemicals.
Page 32
Food Does Not Broil Properly The oven control knob is not set at BROIL position. Temperature control knob is not set at MAX position; Heating indicator will light intermittently. Improper baking rack position. This model is designed for closed door broiling only. Close the door. Always broil with the door closed.
PLEASE READ BEFORE USING YOUR OVEN For Forno Commercial Style Ranges Models: FFSGS6444, FFSGS6356, FFSGS6460, FFSGS6387, FFSGS6439, FFSGS6325 Useful information for your oven: • This oven is very powerful. • To avoid burns, please use oven mitts when manipulation oven racks and be careful not to touch the oven door when in use.
Need help?
Do you have a question about the FFSGS6387-30 and is the answer not in the manual?
Questions and answers
how much space do you need next to a full height cabinet from side of range
The required space next to a Forno FFSGS6387-30 full height cabinet is a minimum of 7 4/5 inches (199 mm).
This answer is automatically generated