Related Manuals for Antunes ES-800
Summary of Contents for Antunes ES-800
- Page 1 ® Egg Station Model ES-800 & ES-1200 Owner’s Manual Manufacturing Numbers: 9300592, 9300594, 9300595, 9300597 & 9300604 www.antunes.com P/N 1011155 Rev. F 02/20...
-
Page 2: Table Of Contents
NOT covered under warranty. • Damage caused by parts or components not provided by Antunes. IMPORTANT! Keep these instructions for future reference. If the unit changes ownership, be sure this manual accompanies the equipment. -
Page 3: Owner Information
Model No.: Serial No.: Mfg. No.: IMPORTANT Antunes reserves the right to change specifications and product design without notice. Such revisions do NOT entitle the buyer to corresponding changes, improvements, additions, or replacements for previously purchased equipment. P/N 1011155 Rev. -
Page 4: Important Safety Information
• This equipment should be serviced by quali- polish lines. fied personnel only. Contact Antunes Technical - Finger marks and smears should be Service for adjustment or repair. removed using soap and water. -
Page 5: Specifications
Permaplug 16 9300597 9300595 (508 mm) (518 mm) (203 mm) Amp., 250 VAC 9300597 9300604 Shipping Weight • ES-1200 & ES-800: 50 lbs (22.6 kg) Net Weight • ES-1200 & ES-800: 43 lbs (19.5 kg) P/N 1011155 Rev. F 02/20 ®... -
Page 6: Installation
Unpacking 1. Remove unit and all packing materials from shipping carton. READY 2'-00" NOTE: If any parts are missing or damaged, BACON contact Antunes Customer Service IMMEDIATELY 2'-30" COOKING at +1-877-392-7856 (toll free). START/STOP POWER 2. Remove information packet. Figure 1. Operating Controls 3. -
Page 7: Operation
EGG STATION OPERATION Trough Vertically insert Pin Cover on Egg Rack here Assembly Vertically insert Pin on Egg Rack here Cover Assembly Hinge Bracket (attached to Cover Assembly) Egg Rack Figure 2. Cover Assembly & Rack Assembly Egg Cooking Procedure 12. -
Page 8: Best Practices
EGG STATION BEST PRACTICES Troubleshooting Eggs leaking out of Egg Troubleshooting for Under Cooked Eggs Rings Level unit - adjust feet if necessary. The unit must be level before use. Before using the unit, adjust Egg Ring Replacement depends on usage but in gen- the legs of the unit as needed and use a level. -
Page 9: Maintenance
EGG STATION MAINTENANCE Daily Cleaning WARNING Turn the power off, unplug the power cord, and 1. Turn the power off, unplug the power cord, and allow the unit to cool down before performing any allow the unit to cool down. service or maintenance. -
Page 10: Checking Cycle Times (Monthly)
EGG STATION MAINTENANCE (continued) Checking Cycle Times (Monthly) CAUTION: Grill surfaces will be hot. Care should be READY taken when operating this piece of equipment. 2'-00" BACON NOTE: A stopwatch is required for this procedure. 2'-30" COOKING POWER START/STOP 1. Turn the power on and allow the unit to preheat NOTE: The following factory pre-set cooking times. -
Page 11: Troubleshooting
Inoperable electrical outlet. Plug into different outlet of same amperage rating. Inoperable power switch. Contact your maintenance person or call Antunes Technical Service at +1-877-392-7854 (toll free). Inoperable power cord. Loose connections. Unit fails to heat. Loose connections. -
Page 12: Control Board Leds
EGG STATION TROUBLESHOOTING (continued) Control Board LEDs BUZZ YELLOW Solid State The Control Board has three on board LEDs (Figure 4) 50 AMP 24-280 VAC Relay 2/T1 1/L1 to determine the status of the unit and to assist in Crouzet STATUS GREEN Bauart... -
Page 13: Wiring Diagram
EGG STATION WIRING DIAGRAM MFG No. 9300592 & 9300604 MFG No. 9300594, 9300595, & 9300597 P/N 1011155 Rev. F 02/20 ®... -
Page 14: Replacement Parts
EGG STATION REPLACEMENT PARTS U T IO T SU ID AD R FA O CA IS SE FL ÄC 2 '- W ER " 2 '- " R EA T/ ST P/N 1011155 Rev. F 02/20 ®... - Page 15 EGG STATION REPLACEMENT PARTS (continued) Item Part Number Description Qty. Item Part Number Description Qty. 0013341 Egg Rack Cover (9300592 & 0700657 Wire Set, PCB/2 SW Board 9300604 ONLY) (not shown) 7002053 Egg Rack Cover (9300594 & 0700670 Wire Set (not shown) 9300597 ONLY) (9300592 &...
-
Page 16: Limited Warranty
This warranty does not cover Travel Time & Mileage in excess of 2 hours (100 miles/160 km) round trip from the nearest authorized service agency. 2. Antunes reserves the right to make changes in design or add any improvements on any product. The right is always reserved to modify equipment because of factors beyond our control and government regulations.
Need help?
Do you have a question about the ES-800 and is the answer not in the manual?
Questions and answers