1. Manuals
  2. Brands
  3. Antunes Manuals
  4. Commercial Food Equipment
  5. MES-1200
  6. Manual

Antunes MES-1200 Manual

Manual egg station with timer
Hide thumbs Also See for MES-1200:
Table of Contents

Advertisement

Quick Links

Manufacturing Numbers 9300605 & 9300606
Place this manual in the Small Equipment/
Miscellaneous section of your Equipment Manual.
Manufactured exclusively for
McDONALD'S ®
BY
ANTUNES
180 KEHOE BLVD.
CAROL STREAM, ILLINOIS 60188, U.S.A.
PHONE: +1-630-784-1000
TOLL FREE: +1-877-392-7854
FAX: +1-630-784-1650
www.antunes.com
Owner Information .....................................................2
General ......................................................................2
Warranty Information .................................................2
Service/Technical Assistance ....................................2
Important Safety Information ....................................3
Specifications .............................................................5
Electrical Ratings .......................................................5
Dimensions ................................................................5
Electrical Cord & Plug Configurations .......................5
Installation ...................................................................6
Unpacking ..................................................................6
Leveling the Unit ........................................................6
Timer Interface ..........................................................6
The unit must be level before use. Before using the unit, adjust the legs of the unit as needed and use a
level (if available) to ensure the unit is level. If a level is not available, pour a small amount of water directly
onto the center of the cool grill surface. If the unit is level, the water should pool in the middle and not drain
toward a certain section of the unit. Make adjustments as required. Turn legs clockwise to shorten or
counter-clockwise to lengthen. See image (Side view of unit).
This manual is for the exclusive use of licensees and employees of McDonald's Systems, Inc.. © McDonald's Corporation All Rights Reserved.
P/N 1011407 Rev. D 03/18
McDonald's
MANUAL EGG STATION
MODEL MES-1200 WITH TIMER
A.J. Antunes & Co.
MES-1200
Scan with mobile device or enter URL
for product and service information.
http://tiny.cc/ajaMES1200

TABLE OF CONTENTS

IMPORTANT
Turn Leg
Clockwise
to shorten.
See back cover for important warranty information.
Operation .....................................................................7
Preparing Unit ............................................................7
Best Practices .............................................................8
Programming ..............................................................9
MES-1200 Setpoint Temperature ..............................9
Maintenance ..............................................................10
Daily Cleaning .........................................................10
Checking Grill Surface Temperature .......................10
Troubleshooting ....................................................... 11
Wiring Diagram .........................................................12
Replacement Parts ...................................................13
LIMITED WARRANTY ...............................................16
Turn Leg
Counter-clockwise
to lengthen.
1

Advertisement

Table of Contents
loading
Need help?

Need help?

Do you have a question about the MES-1200 and is the answer not in the manual?

Questions and answers

Subscribe to Our Youtube Channel

Related Manuals for Antunes MES-1200

Summary of Contents for Antunes MES-1200

  • Page 1: Table Of Contents

    MANUAL EGG STATION MODEL MES-1200 WITH TIMER Manufacturing Numbers 9300605 & 9300606 A.J. Antunes & Co. Place this manual in the Small Equipment/ Miscellaneous section of your Equipment Manual. Manufactured exclusively for McDONALD’S ® ANTUNES 180 KEHOE BLVD. CAROL STREAM, ILLINOIS 60188, U.S.A.

  • Page 2: Owner Information

    This manual provides the safety, installation, and oper- If you experience any problems with the installation ating procedures. We recommend that all information or operation of your unit, contact Antunes Technical contained in this manual be read prior to installing and Service at +1-877-392-7854 (toll free).

  • Page 3: Important Safety Information

    • Do NOT clean this appliance with a water jet. IMPORTANT Antunes reserves the right to change specifications and product design without notice. Such revisions do not entitle the buyer to corresponding changes, improvements, addi- tions, or replacements for previously purchased equipment.
  • Page 4 MANUAL EGG COOKER/STEAMER MANUAL EGG COOKER/STEAMER IMPORTANT SAFETY INFORMATION (continued) • Do NOT use a sanitizing solution or abrasive WARNING materials. The use of these may cause dam- ELECTRICAL SHOCK HAZARD. age to the stainless steel finish. FAILURE TO FOLLOW THE INSTRUCTIONS IN •...

  • Page 5: Specifications

    9300606 Pin & Sleeve. MES-1200 L6-20P, 20 Amp., Shipping Weight 9300605 250 VAC., Straight Twist Lock. • MES-1200: 50 lbs (22.6 kg) Net Weight • MES-1200: 43 lbs (19.5 kg) Dimensions 19 7/16” (493.7 mm) 16 15/16” (403.2 mm) 14 25/32”...

  • Page 6: Installation

    Refer to Figure 1 to become familiar with the Timer shipping carton. interface. The timer has two timing channels, one for the front of the MES-1200 and one for the back. NOTE: If any parts are missing or damaged, con- tact Antunes Customer Service IMMEDIATELY at Each timing channel has the following buttons set to the +1-877-392-7856 (toll free).

  • Page 7: Operation

    Timer 1. Make sure the Timer is seated properly on the 1. Plug in the power cord and turn the MES-1200 on. Timer Bracket and is flush against the front of the The light sensor on the back of the timer senses unit.

  • Page 8: Best Practices

    MANUAL EGG COOKER/STEAMER BEST PRACTICES Troubleshooting Eggs leaking out of Egg Troubleshooting for Under Cooked Eggs Rings 1. Level unit - adjust feet if necessary. The unit must be level before use. Before using the unit, adjust Egg Ring Replacement depends on usage but in gen- the legs of the unit as needed and use a level.

  • Page 9: Programming

    3. Remove the back housing from the timer. The MES-1200 unit. batteries are secured inside the timer with Velcro. B. On the MES-1200, plug in the power cord and turn Carefully remove and replace the batteries and the unit on.

  • Page 10: Maintenance

    Step 4. If temperature 3. Wash, rinse, and sanitize the Top Covers, Egg is above or below range, call Antunes Technical Racks & Rings, and Scrap Pans. Allow to air dry. Service at 630-784-1000 or toll free in the U.S.

  • Page 11: Troubleshooting

    Make sure there is nothing blocking the light sensor on the Light sensor on rear of timer rear of the timer. obstructed. If the troubleshooting steps listed do not solve your problem, contact Antunes Technical Service at +1-877-392-7854 (toll free). P/N 1011407 Rev. D 03/18 McDonald’s...

  • Page 12: Wiring Diagram

    MANUAL EGG COOKER/STEAMER WIRING DIAGRAM P/N 1011407 Rev. D 03/18 McDonald’s...

  • Page 13: Replacement Parts

    MANUAL EGG COOKER/STEAMER REPLACEMENT PARTS P/N 1011407 Rev. D 03/18 McDonald’s...
  • Page 14 MANUAL EGG COOKER/STEAMER REPLACEMENT PARTS (continued) Item Part Description Qty. Item Part Description Qty. 0021760 Nose Piece Weldment 4010187 Transformer, Stepdown (240V/12) 7000674 Grill Platen 4010190 Switch, Momentary 040P138* Lock-nut, Conduit - 1/2” NPT 4010193 PC-Board, Switch-Two Button 0400315 Strain Relief - Cord Connector 7000272 Thermostat, Hi-Limit 2180259...
  • Page 15 MANUAL EGG COOKER/STEAMER NOTES P/N 1011407 Rev. D 03/18 McDonald’s...

  • Page 16: Limited Warranty

    This warranty is exclusive and is in lieu of all other warranties, expressed or implied, including any implied warranty of merchantability or fitness for a particular pur- pose, each of which is expressly disclaimed. The remedies described above are exclusive, and in no event shall Antunes or any of its Divisions be liable for special consequential or incidental damages for the breach or delay in the performance of this warranty.

Table of Contents