Hyundai power products HG4000I-AR1 Manual
  1. Manuals
  2. Brands
  3. Hyundai power products Manuals
  4. Portable Generator
  5. HG4000I-AR1
  6. Manual

Hyundai power products HG4000I-AR1 Manual

Low voltage generator set
Hide thumbs
Table of Contents

Advertisement

Quick Links

Download this manual
LOW VOLTAGE GENERATOR SET
HG4000I-AR1

Advertisement

Table of Contents
loading
Need help?

Need help?

Do you have a question about the HG4000I-AR1 and is the answer not in the manual?

Questions and answers

Subscribe to Our Youtube Channel

Related Manuals for Hyundai power products HG4000I-AR1

Summary of Contents for Hyundai power products HG4000I-AR1

  • Page 1 LOW VOLTAGE GENERATOR SET HG4000I-AR1...

  • Page 2: Safety Instructions

    Warning: Please read the manual carefully before using the unit! 1. SAFETY INSTRUCTIONS Warning: 1. Caution! The exhaust gases are toxic. Do not operate the generator in a room without ventilation! 2. Children must be protected by keeping them at a safe distance from the generator! 3.
  • Page 3 • Do not run the generator in a closed or poorly ventilated area. The gases released by the engine contain carbon monoxide, which is toxic and can cause unconsciousness or death. • Run the generator set according to the power rating stated in the operating instructions. Avoid running the generator set under overload or at excessive speed.
  • Page 4 • Parts of the engine are hot and can cause burns. Pay attention to the warnings on the generator set. • Engine exhaust fumes are toxic. Do not operate the generator in unventilated rooms. When installed in ventilated rooms, the requirements for fire and explosion protection must be observed. •...
  • Page 5 • Never fill up while smoking or near a flame. • Be careful not to spill fuel on the engine and exhaust grille of the generator set when refuelling. • Keep fuel in a suitable container, clean and away from sources of ignition. •...
  • Page 6 workers of the public electricity company working on the network or other persons in contact with the line during a power cut; furthermore, when the public electricity supply is restored, the generator may explode, burn or generate fire in the building's electrical installation. Before connecting electrical appliances to the generator set, it is necessary to check whether their operating voltage and frequency specifications correspond to the technical specifications of the generator set.
  • Page 7 Symbols The following symbols are used in this manual to help differentiate between types of information. The safety symbol is used as a key word to alert you to potential hazards associated with operation and ownership of electrical equipment. Observe all safety instructions to avoid or limit the risk of serious injury or death. This is the safety alert symbol.
  • Page 8 P,or pr e 1, 1 0; n ir blockagB of steam in the fuel tank turn position Top revent 11aporoI c k i n t ett liOl turnfue wind the OFF f u e the fuel release talllk, OFF pœitioll until engim has cooled for at least miHtes.

  • Page 9: Parts Included

    Folding handle - Do not use the folding Battery access cover handle to lift or lower the carry the unit. Parts included Your HG4000i-AR1 power generator comes with the following parts: 1. Battery charger in (2.1A and 1A ports) 12volts 2. Remote control 3. Oil funnel...

  • Page 10: Electrical Panel

    CONTROLS AND FEATURES Electrical panel Ü_J � Fuel tap(9) Oil level indicator light oil level when this light comes Check Starter engine will not operate if this light is Control switch for economy mode (10) Output indicator light - this light comes on Grounding consult an...

  • Page 11: Controls And Features

    CONTROLS AND FEATURES Power panel load management condition When the generator is first started with the remote This generator is equipped with a fi l - f r e e remote control, no voltage is supplied to the power panel for control system for starting and stopping.

  • Page 12: Connecting The Battery

    ASSEMBLY Your generator requires assembly. Battery connection condition This unit is shipped from our factory without oil. It must be supplied with oil and fuel before operation. NOTE If the battery cables are not visible after removing Remove the generator from the carton the cover, please note that they would be glued to 1.

  • Page 13: Operation

    OPERATION Location of the generator Grounding The generator grounding system connects the frame to the NEVER operate the generator in a dry environment. a building, including garages, basements, wet rooms, grounding terminals of the power panel. sheds, enclosures or compartments, including the - The generator (stator winding) is insulated from the frame generator compartment o f a recreational vehicle.
  • Page 14 OPERATION Launcher and electric start condition Launcher and electric start release the switch and wait at least two seconds before 1. Ensure that the generator is on a flat and level attempting to start again. surface. Pull the puller 2. Disconnect all electrical loads from the generator. 8.

  • Page 15: Manual Start

    OPERATION Manual start Manual start condition If the battery is empty or is not able to produce NOTE enough power use the starter to manually start the motor. To manually start the motor and start the Hold the choke lever in the position inverter, please follow the steps below: Move the choke lever to the "STARTER"...
  • Page 16 OPERATION Connection of electrical loads 12V DC output - battery charging Allow the engine to stabilise and warm up for a few 1. Before connecting the charging cable to a battery installed minutes after starting. in a vehicle, disconnect the ground cable Connect and switch on the single-phase of the vehicle battery from the negative (-) battery terminal.

  • Page 17: Overload Operation

    OPERATION Engine shutdown condition Overload operation The overload indicator lights up when the rated load is NOTE exceeded. When the rated load is exceeded, the LED flashes If the engine will not be used for more than two weeks and cuts off power to the receptacles. To get power back, or more, please refer to the storage section for stop the engine, wait for the light to go out and start the information on proper storage and fuel.
  • Page 18 starter generator. starter Starter generator. starter the generator. the generator the generator the generator the generator generator the generator generator the generator generator...
  • Page 19 the generator...
  • Page 20 the generator the generator. the generator the generator. the generator. the generator the generator the generator. the generator the generator...

  • Page 21: Maintenance And Storage

    MAINTENANCE AND STORAGE Overload operation Oil (continued) overload indicator will light up when the rated load Allow oil to drain completely. is exceeded. When the maximum load is reached, (0.6 quart) of oil replace light will flash and tank cap/dipstick. DO NOT FILL.
  • Page 22 generator *Aeffectuate by experienced or well-informed owners or trained repairers.
  • Page 23 the generator The generator the generator the generator. the generator the generator the generator. the generator The generator the generator. launcher the generator the generator the generator...
  • Page 24 electric starter and launcher - Guaranteed sound power level: 96 dB (A) - Sound power level measured at 4 m: LpA = 75.80 dB (A) LwA = 95.82 dB (A) K = 0.424 dB the generator 13.5 - Max. altitude ........... 1000m 63,7 Your Hyunday product is tested and calibrated...
  • Page 25 Î c::::s :!fnr:: ::::c CIRCUIT BREAKER OUTPUT PANEL AC OUT1 AC OUT î JL_Br c::::s cc:: - -=-□ c< c:: UNIT RCONTROL < W/ L SUB COIL t:IJl COMBINATION SWITCH I"'"' STARTER BATTE SP1ÀRKING UN1T PLUG STEPPING MOTOR -c:s (THROTTLE) E .
  • Page 26 STEP P TOR...
  • Page 27 The generator The generator the generator the generator Starter the starter The generator the generator The generator The generator swap technique...
  • Page 28 BUILDER compliance -Z1 31270 Cugnaux- France Tel: +33 (0)5.34.502.502Fax : +33 (0)5.34.502.503 Declares that the machine designated b e l o w : INVERTER GENERATOR SET HG4000I-AR1 Serial number: 20200719815-20200719914 "machinery" 2006/42/EC A lad000/14/EC 2005/88/EC 014/30/EU chniques following: Name and address of the laboratory measuring the noise:...
  • Page 29 GUARANTEE GUARANTEE The manufacturer guarantees the product against defects in materials and workmanship for a period of 2 years from the date of original purchase. The warranty applies if the product is for domestic use. The warranty does not extend to failures due to normal wear and tear and damage. The manufacturer agrees to replace parts classified as defective by the designated distributor.
  • Page 30 PRODUCT FAILURE WHAT IF MY MACHINE BREAKS DOWN? If you bought your product in a shop : a) Empty the fuel tank. b) Make sure that your machine is complete (accessories included) and clean! If this is not the case, the repairer will refuse the machine.
  • Page 31 EXCLUSIONS OF COVER THE GUARANTEE DOES NOT COVER : • The start-up and settings of the product. • Damage resulting from normal wear and tear of the product. • Damage resulting from improper use of the product. • Damage resulting from installation or start-up that is not in accordance with the user manual. •...
  • Page 32 For any request, please contact us: BUILDER SAS 32. rue Aristide Bergès Z1 31270 Cugnaux. France Tel+33 (0) 5 34 502.502 Fax - +33 (0) 5 34 502 503 http//wwyundaipower-frcom/ Made in the People's Republic of China (PRC) Imported by BUILDER SAS. France...

This manual is also suitable for:

3661602011374

Table of Contents