Table of Contents
Advertisement
OM4005 10/96
Lubrication and Service
Prior to each operating shift, a "walk around" inspection
should be performed. Check the truck for general
condition. Look for evidence of hydraulic leaks; check
all lights and mirrors for clean and unbroken lenses;
check operator's cab for clean and unbroken glass;
check frame, sheet metal and body for cracks. Notify
the proper maintenance authority if any discrepancies
are found. Give particular attention to the following:
CHECK ALL FLUID LEVELS
a. Engine oil --
NOTE: Refer to engine manufacturer service
manual for oil recommendations.
b. Engine Fuel Filters -- Drain water from fuel filter
elements.
c. Radiator -- Check coolant level and fill with proper
mixture as shown in Cooling System Recommen-
dation Chart.
d. Battery -- Check electrolyte level and add water if
necessary.
e. Hydraulic tank -- Check oil level in tank, add if
necessary. Lube key ''D'', C-4 hydraulic fluid.
NOTE: DO NOT OVERFILL.
Refer to "Hydraulic Tank Filling Instructions",
page 4-1.
f. Transmission -- Check oil level. If necessary, add
oil. Lube key ''D'', C-4 hydraulic fluid.
NOTE: Check transmission oil level with truck
level, engine running, oil at operating tempera-
ture, and transmission in neutral. Oil level should
be not more than half full in sight glass or just
trickle from top (full) petcock (or should be just
below the FULL mark). DO NOT OVERFILL.
g. Fuel Tank -- Fill as required.
h. Final drive -- Check oil level in sight glass. Truck
should be on level surface; oil should fill sight
glass.
AIR CLEANERS
a. Check service indicator. If indicator shows red,
replace with clean filters. Reset indicator by press-
ing button on top of indicator.
b. Empty air cleaner dust cups. See Section ''C'' of
the service manual. Remove and empty air
cleaner dust cups.
10 HOUR (DAILY) INSPECTION
Truck Serial Number ____________________________
Site Unit Number ______________________________
Date:______________Hour Meter_________________
Serviceperson Name___________________________
COMMENTS
Maintenance - Section 4
Page 4-3
√
'
INITIALS
d
Advertisement
Table of Contents
