Repairing Rear Brake Bosch Biriii (Vehicles With Front And Four-Wheel Drive) - Skoda Octavia II 2004 Workshop Manual

2.8

Repairing rear brake Bosch BIRIII (vehicles with front and four-wheel drive)

Note
Brake inspection ⇒ page 8
♦
After replacing the brake pads, depress brake pedal firmly several times when the vehicle is stationary to
♦
ensure the brake pads are properly seated in their normal operating position.
Use the brake filling and bleeding device , e.g. -VAS 5234- , to drain the brake fluid from the brake fluid
♦
reservoir.
The brake pedal load , e.g. -V.A.G 1869/2- , must be inserted before removing a brake caliper or separating
♦
a brake hose from the brake caliper.
1 - Screw, 70 Nm + 90°
❑ replace after each re‐
moval
2 - ABS speed sensor (vehi‐
cles with four-wheel drive)
❑ clean the inner surface
of the hole before insert‐
ing the sensor and
brush over with a hot
bolt paste -
G 052 112 A3- .
3 - Screw, 8 Nm
4 - ABS speed sensor (vehi‐
cles with front-wheel drive)
5 - Wheel-bearing housing (ve‐
hicles with front-wheel drive)
❑ Assignment ⇒ Electron‐
ic Catalogue of Original
parts
6 - Wheel hub with wheel bear‐
ing (vehicles with front-wheel
drive)
❑ Assignment ⇒ Electron‐
ic Catalogue of Original
parts
7 - Tighten screw 180 Nm +
Protected by copyright. Copying for private or commercial purposes, in part or in whole, is not permitted
unless authorised by ŠKODA AUTO A. S. ŠKODA AUTO A. S. does not guarantee or accept any liability
180° (vehicles with front-wheel
with respect to the correctness of information in this document. Copyright by ŠKODA AUTO A. S.�
drive)
❑ replace after each re‐
moval
❑ removing and installing
⇒ chassis, axles, steer‐
ing; Rep. gr. 42
8 - Protection plate
❑ for vehicles with front-wheel drive, 3 holes
❑ for vehicles with four-wheel drive, 4 holes
❑ Assignment ⇒ Electronic Catalogue of Original parts
9 - Screw, 12 Nm
❑ for vehicles with front-wheel drive, 3 screws
❑ for vehicles with four-wheel drive, 4 screws
❑ Assignment ⇒ Electronic Catalogue of Original parts
.
Octavia II 2004 ➤ , Octavia II 2010 ➤
Brake systems - Edition 11.2017
125