Advertisement
Quick Links
Product overview
10
9
8
7
6
Fig. 1: Schematic illustration, e.g. TFC-SC-FT-0-ED-TDF
1
Casing
2
Fixing brackets
3
Spigot with lip seal
4
Internal measuring tube
5
Diffuser face
Installation and mainte-
nance manual
TFC
Ceiling mounted particulate filters
1
TFC Ceiling mounted particulate filters
GB/en
2
6
Clamping mechanism for the filter element
7
Clamping screws
8
Filter element
9
Filter fitting
10
Outside pressure measurement point
TROX GmbH
Heinrich-Trox-Platz
47504 Neukirchen-Vluyn
Germany
Phone: +49 (0) 2845 2020
Fax: +49 (0) 2845 202265
E-mail: trox@trox.de
Internet: http://www.trox-
technik.com
3
4
5
1
Advertisement
Subscribe to Our Youtube Channel
Related Manuals for Trox Technik TFC
Summary of Contents for Trox Technik TFC
- Page 1 Phone: +49 (0) 2845 2020 Fax: +49 (0) 2845 202265 E-mail: trox@trox.de Internet: http://www.trox- Ceiling mounted particulate filters technik.com Product overview Fig. 1: Schematic illustration, e.g. TFC-SC-FT-0-ED-TDF Casing Clamping mechanism for the filter element Fixing brackets Clamping screws Spigot with lip seal Filter element...
-
Page 2: Important Notes
The obligations agreed in the order, the general TFC can be used in supply air and extract air sys- terms and conditions, the manufacturer's terms of tems. They are suitable for the fitting of Mini Pleat... - Page 3 Industrial safety helmet Industrial safety helmets protect the head from falling objects, suspended loads, and the effects of striking the head against stationary objects. TFC Ceiling mounted particulate filters...
-
Page 4: Supply Package, Transport And Storage
Store the product only in its original packaging Protect the product from the effects of weather Protect the product from humidity, dust and contamination Storage temperature: -10 °C to 50 °C. Relative humidity: 95% max., no condensation TFC Ceiling mounted particulate filters... - Page 5 Safety shoes ② TFC-/.../T/.. ③ TFC can weigh up to 38 kg, depending on the con- ① ④ struction. Use only approved and adequately sized suspension systems. Fixing material is not included in the supply package. Only work in pairs; preferably use a lift.
- Page 6 ③ ② ① ④ and avoid cumbersome cleaning procedures at the time of commissioning. Fig. 3: Fixing to suspended ceiling, TFC-xx-FC with suspended ceiling support (4 pieces) Suspended ceiling Levelling foot Angle adjusting screw Diffuser face Note: The filter casing TFC is installed on...
- Page 7 ② ⑤ ② ⑤ ① ① ③ ④ Fig. 4: TFC connection to suspended ceiling T-bar ceiling TFC-xx-AIRNAMIC, plasterboard ceiling TFC-xx-CC-ED, clip-in tile ceiling TFC filter casing TFC-xx-CC-ID, clip-in tile ceiling Diffuser face, ED position TFC-xx-ED, plasterboard ceiling Diffuser face, ID position...
-
Page 8: Connecting The Ductwork
Connecting the ductwork Connecting the ductwork Electrical connection Type TFC ceiling mounted particulate filters are Connecting the electric actuator available with various spigots: Personnel: Side entry circular spigot Skilled qualified electrician Top entry circular spigot Side entry rectangular spigot ... - Page 9 Volume flow rate balancing is required before initial commissioning. ⑦ ① Units with an optional volume flow limiter (TFC- SCV): Once the volume flow rate has been set (by ② others), it will be maintained (mechanical self-pow- ③...
-
Page 10: Maintenance
The service life of a filter depends mainly on how polluted the air is. Check the filter in intervals that are short enough so that you can anticipate any defects or problems before they actually occur. TFC Ceiling mounted particulate filters... - Page 11 (Fig. 8/3). For diffuser face sealing cap into place. type PCD (PROCONDIF): Remove the cen- tral honeycomb. Reinstall the diffuser face. Remove the central fixing screw (Fig. 8/2) and then the diffuser face. TFC Ceiling mounted particulate filters...
- Page 12 If this value is exceeded, adjust the clamping screws or the clamping frame; also check the seal, test groove and filter element for damage. Then repeat the sealing integrity test. TFC Ceiling mounted particulate filters...
- Page 13 Before you start changing filters, switch off the ven- Minus (–) - to the 'Minus' measurement point (–) tilation and air conditioning system, or close the shut-off damper (if any) on TFC. Temporary measurement: Temporary differential Ä ‘Removing the Remove the diffuser face, pressure measurement with a mobile measurement diffuser face’...
- Page 14 To avoid downtime of the ventilation and air con- ditioning system, we recommend you to always have the required filters in stock. To order replacement fil- ters: https://www.trox.de/onlineshop/filtergeraete- und-filterelemente-1df986693c21980d TFC Ceiling mounted particulate filters...
Need help?
Do you have a question about the TFC and is the answer not in the manual?
Questions and answers