Advertisement

Quick Links

P/N 126733-01 Rev. H 01/2019
P126733-01
Ce manuel est disponible en francais, simplement
en faire la demande. Numéro de la pièce 126733-02
INSTALLER: Leave this manual with the appliance.
CONSUMER: Retain this manual for future
reference.
This appliance may be installed in an aftermarket permanently located, manufactured home (USA only)
or mobile home, where not prohibited by local codes. This appliance is only for use with the type of gas
indicated on the rating plate. This appliance is not convertible for use with other gases, unless a certified kit
f i r e - p a r t s . c o m
is used.
Cet appareil peut installé dans une maison préfabriquée (mobile) déjà installée à demeure, si les réglements
locaux le permettent. Ce appareil doit être utilisé uniquement avec le type de gaz indiqué sure la plaque
signalétique. Cet appareil ne peut être converti à d'autres gaz, sauf si une trousse de conversion est utilsée.
WARNING:
FIRE OR EXPLOSION HAZARD
Failure to follow safety warnings exactly could
result in serious injury, death, or property damage.
- Do not store or use gasoline or other flammable
vapors and liquids in the vicinity of this or any
other appliance.
- WHAT TO DO IF YOU SMELL GAS
• Do not try to light any appliance.
• Do not touch any electrical switch; do not use
any phone in your building.
• Leave the building immediately.
• Immediately call your gas supplier from a neigh-
bor's phone. Follow the gas supplier's instruc-
tions.
• If you cannot reach your gas supplier, call the
fire department.
- Installation and service must be performed by
a qualified installer, service agency or the gas
supplier.
Installation and Operation Instructions
Sentinel™ Series Direct-Vent Gas Fireplaces
Models
C
US
Report No. F09 -099
Installateur : Laissez cette notice avec l'appareil.
Consommateur : Conservez cette notice pour
consultation ultérieure.
RISQUED'INDENDIE OU D'EXPLOSION
Le non-respect Des avertissements de sécurité
pourrait d'entraîner des blessures graves, la mort
ou des dommages matériels.
- Ne pas entreposer ni utilizer d'essence ni d'autres
- QUE FAIRE SI VOUS SENTEZ UNE ODEUR DE GAZ:
• Ne pas tenter d'allumer d'appareil.
• Ne touchez à aucan interrupteur. Ne pas vous servir
• Sortez immédiatement de bâtiment.
• Appelez immédiatement votre fournisseur de
• Si vous ne pouvez rejoindre le fournisseur de gaz,
- L'installation et l'entretien doivent être assurés par
Sentinel36TEN
Sentinel42TEN
AVERTISSEMENT:
vapeurs ou liquides inflammables dans le voisinage
de cet appareil ou de tout autre appareil.
des téléphones se trouvant dans le bâtiment où
vous trouvez.
gaz depuis un voisin. Suivez les instructions du
fournisseur.
appelez le service des incindies.
un installateur ou un service d'entretien qualifié
ou par le fournisseur de gaz.
Sentinel36TEP
Sentinel42TEP

Advertisement

Table of Contents
loading
Need help?

Need help?

Do you have a question about the Sentinel Series and is the answer not in the manual?

Questions and answers

Summary of Contents for Astria Fireplaces Sentinel Series

  • Page 1 Installation and Operation Instructions Sentinel™ Series Direct-Vent Gas Fireplaces Models P/N 126733-01 Rev. H 01/2019 Sentinel36TEN Sentinel36TEP Sentinel42TEN Sentinel42TEP P126733-01 Report No. F09 -099 Ce manuel est disponible en francais, simplement en faire la demande. Numéro de la pièce 126733-02 INSTALLER: Leave this manual with the appliance.
  • Page 2: Safety And Your Fireplace

    SAFETY AND YOUR FIREPLACE See attached color flyer for proper color representation DANGER HOT GLASS WILL CAUSE BURNS. DO NOT TOUCH GLASS UNTIL COOLED. NEVER ALLOW CHILDREN TO TOUCH GLASS. A barrier designed to reduce the risk of burns from the hot viewing glass is pro- vided with this appliance and shall be installed for the protection of children and other at-risk individuals.
  • Page 3 La sécurité et Safety and Your Seguridad y su votre foyer Fireplace chimenea All parts of your ¡Todas las partes de la Toutes les parties de votre IHP fireplace get chimenea IHP se ponen foyer IHP deviennent EXTREMELY HOT! EXTRÊMEMENT CHAUDES ! MUY CALIENTES! ...
  • Page 4: Table Of Contents

    Thank you for your purchase. We appreciate your business! Please carefully read and follow all instructions in this manual. Pay special attention to all warnings and safety information. Following these safety, care, and operation instructions will help ensure many years of dependable and enjoyable service from your fireplace.
  • Page 5 IMPORTANT SAFETY INFORMATION Important Safety Informa- L’information de sûreté Información importante de importante tion seguridad 1. WARNING: Do not operate appliance 1. AVERTISSEMENT. Ne pas utiliser l’appareil 1. ADVERTENCIA: No opere el artefacto con el with the glass front removed, cracked, si le panneau frontal en verre n’est pas en frente de vidrio quitado, agrietado o roto.
  • Page 6 SAFETY Continued Carbon Monoxide Poisoning: Early signs of carbon monoxide poison- Installation and repair should be done by a qualified ing resemble the flu, with headaches, dizziness or nausea. If you have service person. The appliance should be inspected these signs, the fireplace may not be working properly. Get fresh air before use and at least annually by a professional at once! Have fireplace serviced.
  • Page 7: Local Codes

    SAFETY Continued the National Electrical Code, ANSI/NFPA 70 or Canadian Electrical 6. Have venting system inspected annually by a qualified service Code, CSA C22.1. person. If needed, have venting system cleaned or repaired. See Cleaning and Maintenance, Page 27. 9. Do not use fireplace if any part has been exposed to or under water.
  • Page 8: Product Features

    PRODUCT FEATURES These are a few facts that can help you understand and enjoy your • This fireplace may be installed in any room of your house provided direct-vent fireplace: all local codes and these installation instructions are followed. • The venting system may be routed to the outside of your home in •...
  • Page 9 PRE-INSTALLATION Continued " (740 mm) 36" Model " (883 mm) 42" Model Requires IHP 5" (127 mm) I.D. 8" (203 mm) O.D. Direct-Vent Pipe " (302 mm) 36" Model " (346 mm) 42" Model " (521 mm) 36" Model 24" (610 mm) 42"...
  • Page 10 PRE-INSTALLATION Continued CLEARANCES Minimum clearances to combustibles for the fireplace are as follows: *Back and sides 1" (26 mm) Perpendicular walls 6" (153 mm) 44" (1118 mm) Floor 0" (0 mm) 36" Model Ceiling to louver opening 42" (1067 mm) 48"...
  • Page 11: Location Of Termination Cap

    LOCATION OF TERMINATION CAP Fixed Openable Fixed Closed Closed Openable TERMINATION CAP AIR SUPPLY INLET GAS METER RESTRICTED AREA (TERMINATION PROHIBITED) I = clearance to service regulator vent outlet [*72" (182.9 cm) A = clearance above grade, veranda, porch, deck, or balcony [*12"...
  • Page 12: Venting Installation

    VENTING INSTALLATION NOTICE: Read these instructions completely before WARNING: This gas fireplace and vent assembly attempting installation. must be vented directly to the outside. The venting system must NEVER be attached to a chimney serving These models are tested and approved for use with an IHP (direct- a separate solid fuel burning appliance.
  • Page 13 VENTING INSTALLATION Continued 5. Noncombustible Exterior Wall: Position horizontal vent cap in center of the 8-1/2" round hole and attach to exterior wall with Female Locking four wood screws provided. Before attaching vent cap to exterior Lugs wall, run a bead of non-hardening mastic (pliable sealant) around outside edges to make a seal between it and outside wall.
  • Page 14 VENTING INSTALLATION Continued Horizontal Termination Configurations Cut Siding Away to Fit Figure 15 shows a configuration for venting with horizontal termi- Standoff nation with a chart of critical minimum and maximum dimensions which MUST be met. Standoff Wood Figure 16, Page 15, shows a configuration for venting with horizontal Screw termination using two 90°...
  • Page 15 VENTING INSTALLATION Continued 2. Assemble desired lengths of pipe and elbows necessary to reach from fireplace flue up through firestop. Be sure all pipe and elbow connections are fully twist-locked (see Figure 9, Page 13). 3. Cut a hole in the roof using locating hole as a center point. (Cover any exposed open vent pipes before cutting hole in roof.) The 11- 1/2"...
  • Page 16 VENTING INSTALLATION Continued NOTE: If vent pipe passes through any occupied areas above first floor, Venting with Two 90° Elbows including storage spaces and closets, you must enclose pipe. You may frame and sheetrock enclosure with standard construction material. Make Vertical (V Horizontal (H) sure and meet the minimum allowable clearances to combustibles.
  • Page 17: Fireplace Installation

    FIREPLACE INSTALLATION CHECK GAS TYPE IMPORTANT: Install main gas valve (equipment shutoff valve) in an accessible location. The main gas valve is for turning on or shutting Use proper gas type for the fireplace unit you are installing. If you off the gas to the appliance.
  • Page 18 FIREPLACE INSTALLATION Continued CONNECTING FIREPLACE TO GAS SUPPLY WARNING: Use pipe joint sealant that is resistant Installation Items Needed to liquid petroleum (LP) gas. • 5/16" hex socket wrench or nut-driver We recommend that you install a sediment trap/drip leg in supply •...
  • Page 19 FIREPLACE INSTALLATION Continued REMOVING/REPLACING GLASS DOOR Equipment Shutoff Valve CAUTION: Do not operate this fireplace with a bro- Propane/LP ken glass door panel or without the glass door panel Supply Tank securely in place. For replacement part information see Replacement Parts, Page 31. CAUTION: Wear gloves and safety glasses while handling or removing broken glass.
  • Page 20 FIREPLACE INSTALLATION Continued Replacing Glass Door 3. Place volcanic stone around base of burner. Make sure burner ports are not covered (see Figure 30, Page 21). 1. Position door frame in front of firebox opening with bottom of 4. Place ember flakes around front and sides of burner and on burner door tilted away from firebox (see Figure 27, Page 19).
  • Page 21 FIREPLACE INSTALLATION Continued To Gas Supply Volcanic stone Equipment (Natural) Shutoff Valve Control Valve To External Regulator (Propane/LP) Flexible Gas Line, Do NOT Kink Figure 30 - Installing Volcanic stone Figure 33 - Connecting/Disconnecting Gas Line to Control Valve WARNING: Never use an open flame to check for a leak.
  • Page 22 FIREPLACE INSTALLATION Continued GAS CONTROL MODULE SYSTEM Learn Button AUX Connection The module has 2 special features built into the system. CONTINUOUS PILOT FEATURE This allows the change from a spark to pilot system to a standing pilot system. There is a switch located on the right side of the module that reads CONTINUOUS PILOT ON/OFF.
  • Page 23: Installer - Attaching Safety In Operation Warnings

    INSTALLER INSTRUCTIONS - ATTACHING SAFETY IN OPERATION WARNINGS It is the installers responsibility to ensure these warnings are properly affixed during installation. These warning labels are a critical step in informing consumers of safe operation of this appliance. ATTACHING SAFETY IN OPERATION WARNINGS APPOSITION DES MISES EN GARDE RELATIVES COLOCACIÓN DE ADVERTENCIAS DE SEGURIDAD It is required that the safety instruction labels fur-...
  • Page 24: Operation

    OPERATION FOR YOUR SAFETY LIGHTING READ BEFORE LIGHTING INSTRUCTIONS NOTICE: During initial operation of new fireplace, burn- WARNING: If you do not follow these instructions ing logs will give off a paper-burning smell. Orange exactly, a fire or explosion may result causing property flame will also be present.
  • Page 25: Homeowner's - Attaching Safety In Operation Warnings

    HOMEOWNER’S INSTRUCTIONS - ATTACHING SAFETY IN OPERATION WARNINGS ATTACHING SAFETY IN OPERATION WARNINGS APPOSITION DES MISES EN GARDE RELATIVES COLOCACIÓN DE ADVERTENCIAS DE SEGURIDAD À LA SÉCURITÉ D’UTILISATION EN OPERACIÓN Your fireplace has been furnished with safety instruc- tion labels that are to be affixed to the operation and Votre foyer a été...
  • Page 26: Inspecting Burners

    INSPECTING BURNERS Check pilot flame pattern and burner flame patterns often. BURNER FLAME PATTERN Burner flames will be steady, not lifting or floating. Flame patterns will PILOT ASSEMBLY be different from unit to unit and will vary depending on installation The pilot assembly is factory preset for the proper flame.
  • Page 27: Cleaning And Maintenance

    CLEANING AND MAINTENANCE WARNING: Turn off fireplace and let cool before CAUTION: Do not vacuum if pieces are hot. cleaning. Use only glass door replacement intended for this fireplace (see Replacement Parts, Page 37 for detail on ordering). No substitutions CAUTION: You must keep control areas, burners may be made.
  • Page 28: Troubleshooting

    TROUBLESHOOTING WARNING: Turn off fireplace and let cool before servicing. Only a qualified service person should service and repair fireplace. CAUTION: Never use a wire, needle or similar object to clean pilot. This can damage pilot unit. NOTE: All troubleshooting items are listed in order of operation. OBSERVED PROBLEM POSSIBLE CAUSE REMEDY...
  • Page 29 TROUBLESHOOTING Continued WARNING: If you smell gas • Shut off gas supply. • Do not try to light any appliance. • Do not touch any electrical switch; do not use any phone in your building. • Leave the building immediately •...
  • Page 30: Parts

    PARTS MODEL CATALOG NO. DESCRIPTION MODEL CATALOG NO. DESCRIPTION Sentinel36TEN F1577 SENTINEL™ 36" Natural HER White Brick Sentinel42TEN F1581 SENTINEL 42" Natural HER White Brick Sentinel36TEN F1578 SENTINEL 36" Natural STK White Brick Sentinel42TEN F1582 SENTINEL 42" Natural STK White Brick Sentinel36TEP F1579 SENTINEL 36"...
  • Page 31 PARTS This list contains replaceable parts used in your fireplace. When ordering parts, follow the instructions listed under Replacement Parts on Page 37 of this manual. WARNING: Contact an IHP dealer to obtain any of these parts. Never use substitute materials not approved by IHP.
  • Page 32 PARTS WARNING: Failure to position the parts in accor- dance with these diagrams or failure to use only parts f i r e - p a r t s . c o m specifically approved with this appliance may result in property damage or personal injury.
  • Page 33 PARTS BURNER ASSEMBLY This list contains replaceable parts used in your fireplace. When ordering parts, follow the instructions listed under Replacement Parts on Page 37 of this manual. This table uses catalog numbers for clarity on models. WARNING: Contact an IHP dealer to obtain any of these parts. Never use substitute materials not approved by IHP.
  • Page 34 PARTS REFRACTORY PARTS MODEL CATALOG NO. DESCRIPTION MODEL CATALOG NO. DESCRIPTION Sentinel36TEN F1577 SENTINEL™ 36" Natural HER White Brick Sentinel42TEN F1581 SENTINEL 42" Natural HER White Brick Sentinel36TEN F1578 SENTINEL 36" Natural STK White Brick Sentinel42TEN F1582 SENTINEL 42" Natural STK White Brick Sentinel36TEP F1579 SENTINEL 36"...
  • Page 35 PARTS REFRACTORY PARTS CATALOG DESCRIPTION QTY. J7809 Rear Refractory, Herringbone 42" White • J7810 Rear Refractory, Herringbone 36" White • J7811 Rear Refractory, Stacked 42" White • J7812 Rear Refractory, Stacked 36" White • J7813 Left Refractory, Herringbone 42" White •...
  • Page 36: Specifications

    SPECIFICATIONS SENTINEL36TEN SENTINEL36TEP • Rating: 33,500 Btu/hr • Rating: 31,000 Btu/hr • Gas Type: Natural Gas Only • Gas Type: Propane/LP Gas Only • Ignition: Electronic • Ignition: Electronic • Manifold Pressure: 3.5" W.C. • Manifold Pressure: 10" W.C. • Minimum Inlet Supply Pressure: 5" W.C. •...
  • Page 37: Technical Service

    TECHNICAL SERVICE 4. The description of the part. 5. The quantity required. You may have further questions about installation, operation, or 6. The installation date of the fireplace. troubleshooting. Please contact your IHP dealer for any questions If you encounter any problems or have any questions concerning the or concerns a.
  • Page 38 NOTES ______________________________________________________ ______________________________________________________ ______________________________________________________ ______________________________________________________ ______________________________________________________ ______________________________________________________ ______________________________________________________ ______________________________________________________ ______________________________________________________ ______________________________________________________ ______________________________________________________ ______________________________________________________ _____________________________________________________ ______________________________________________________ f i r e - p a r t s . c o m ______________________________________________________ ______________________________________________________ ______________________________________________________ ______________________________________________________ ______________________________________________________ ______________________________________________________ ______________________________________________________ ______________________________________________________ ______________________________________________________ ______________________________________________________ ______________________________________________________ _____________________________________________________ ______________________________________________________ ______________________________________________________...
  • Page 39: Warranty

    Innovative Hearth Products Astria Brand Gas Fireplace ® Limited Lifetime Warranty THE WARRANTY Innovative Hearth Products ("IHP") Limited Lifetime Warranty warrants your Astria brand gas fireplace ("Product") to be free from defects in materials and workmanship ® at the time of manufacture. The product body, firebox and barrier carry the Limited Lifetime Warranty. Ceramic glass carries the Limited Lifetime Warranty against thermal breakage only.
  • Page 40 Astria.us.com Record the following important information about your fireplace: Fireplace model number Fireplace serial number Date fireplace was Installed Type of gas fireplace uses Dealer name f i r e - p a r t s . c o m Innovative Hearth Products (IHP) reserves the right to make changes at any time, without notice, in design, materials, specifications, prices and also to discontinue colors, styles and products.

Table of Contents