Table of Contents
Advertisement
Quick Links
P/N 126754-01 REV. K 03/2019
Ce manuel est disponible en francais, simplement en
faire la demande. Numéro de la pièce 126754-02.
P126754-01
INSTALLER: Leave this manual with the appliance.
CONSUMER: Retain this manual for future
reference.
Decorative Product: Not for use as a heating
appliance.
This appliance may be installed in an aftermarket permanently located, manufactured home (USA only) or mobile
home, where not prohibited by local codes. This appliance is only for use with the type of gas indicated on the
rating plate. This appliance is not convertible for use with other gases, unless a certified kit is used.
Cet appareil peut installé dans une maison préfabriquée (mobile) déjà installée à demeure, si les réglements
locaux le permettent. Ce appareil doit être utilisé uniquement avec le type de gaz indiqué sure la plaque
signalétique. Cet appareil ne peut être converti à d'autres gaz, sauf si une trousse de conversion est utilsée.
WARNING:
FIRE OR EXPLOSION HAZARD
Failure to follow safety warnings exactly could
result in serious injury, death, or property damage.
- Do not store or use gasoline or other flammable
vapors and liquids in the vicinity of this or any
other appliance.
- WHAT TO DO IF YOU SMELL GAS
• Do not try to light any appliance.
• Do not touch any electrical switch; do not use
any phone in your building.
• Leave the building immediately.
• Immediately call your gas supplier from a neigh-
bor's phone. Follow the gas supplier's instruc-
tions.
• If you cannot reach your gas supplier, call the
fire department.
- Installation and service must be performed by
a qualified installer, service agency or the gas
supplier.
Installation and Operation Instructions
Mission™ B-Vent Fireplaces
Electronic Ignition System
Models
PFS
®
C
US
Report No. F09-143
Installateur : Laissez cette notice avec l'appareil.
Consommateur : Conservez cette notice pour
consultation ultérieure.
NOTICE: Fireplace is not to be operated by a
thermostat.
Mission36TEN
AVERTISSEMENT:
RISQUED'INDENDIE OU D'EXPLOSION
Le non-respect Des avertissements de sécurité
pourrait d'entraîner des blessures graves, la mort
ou des dommages matériels.
- Ne pas entreposer ni utilizer d'essence ni d'autres
vapeurs ou liquides inflammables dans le voisinage
de cet appareil ou de tout autre appareil.
- QUE FAIRE SI VOUS SENTEZ UNE ODEUR DE GAZ:
• Ne pas tenter d'allumer d'appareil.
• Ne touchez à aucan interrupteur. Ne pas vous servir
des téléphones se trouvant dans le bâtiment où
vous trouvez.
• Sortez immédiatement de bâtiment.
• Appelez immédiatement votre fournisseur de
gaz depuis un voisin. Suivez les instructions du
fournisseur.
• Si vous ne pouvez rejoindre le fournisseur de gaz,
appelez le service des incindies.
- L'installation et l'entretien doivent être assurés par
un installateur ou un service d'entretien qualifié
ou par le fournisseur de gaz.
Mission42TEN
Advertisement
Table of Contents
Related Manuals for Astria Fireplaces Mission42TEN
Summary of Contents for Astria Fireplaces Mission42TEN
- Page 1 Mission™ B-Vent Fireplaces Electronic Ignition System P/N 126754-01 REV. K 03/2019 Models Ce manuel est disponible en francais, simplement en faire la demande. Numéro de la pièce 126754-02. Mission42TEN Mission36TEN ® Report No. F09-143 P126754-01 INSTALLER: Leave this manual with the appliance.
-
Page 2: Table Of Contents
TABLE OF CONTENTS Thank you for your purchase. We appreciate your business! Safety....................2 Please carefully read and follow all instructions in this manual. Pay Unpacking..................4 special attention to all warnings and safety information. Introduction..................4 Following these safety, care, and operation instructions will help Selecting Location................ - Page 3 SAFETY Continued 3. If you smell gas State of Massachusetts: The installation must be made • shut off gas supply by a licensed plumber or gas fitter in the Commonwealth • do not try to light any appliance of Massachusetts. •...
-
Page 4: Unpacking
SAFETY Continued COMMONWEALTH OF MASSACHUSETTS REQUIREMENTS 20. Provide adequate clearances around air openings. These appliances are approved for installation in the US state of Mas- 21. Children and adults should be alerted to the hazards of high surface sachusetts if the following additional requirements are met: temperature and should stay away to avoid burns or clothing ignition. -
Page 5: Selecting Location
INTRODUCTION Continued 2. Consider a location where heat output would not be affected by drafts, WARNING: Installation of this appliance should be air conditioning ducts, windows or doors. done by a qualified service person well trained in the 3. A location that avoids the cutting of joists or roof rafters will make instal- installation of such appliances. -
Page 6: Product Specifications
PRODUCT SPECIFICATIONS GAS RATING - NATURAL Mission36TEN Mission42TEN Max. Input Rating: 40,000 Btu/Hr 45,000 Btu/Hr Manifold Pressure: 3.5" WC (.87 kPa) 3.5" WC (.87 kPa) Minimum Supply Pressure: 4.5" WC (1.12 kPa) 4.5" WC (1.12 kPa) Maximum Supply Pressure: 10.5" WC (2.62 kPa) 10.5"... -
Page 7: Pre-Installation Preparation
Spacer Surround 0 cm/po 3" (7.6 cm) Clearance " (3.8 cm) Max. 0 cm/ Mission36TEN Mission42TEN Front Face (F0860, F0862) (F0866, F0868) Drywall 14" (35.6 cm) 15" (38 cm) Figure 3 - Minimum Clearances (Top View) 8" (20.3 cm) 9" (22.9 cm) Figure 5 - Mantel Clearances - Side View (Cross Section) 1"... - Page 8 NOTE: If 1/2" NPT black iron pipe does not mate with fitting at the end of flexible gas line, remove fitting and replace with a 37 degree flare 3/4"-12, 1/2" NPT (female) fitting. Mission36TEN Mission42TEN (F0860, F0862) (F0866, F0868) WARNING: When finishing appliance, do not over- "...
-
Page 9: Venting Installation
VENTING INSTALLATION A B-type venting system must be connected to appliance for venting IMPORTANT NOTICE to the outside of building. NFPA 54 defines minimum space requirements for the The following section is provided as a guide to a standard B-type installation of this appliance. - Page 10 VENTING INSTALLATION Continued If venting horizontally through a side wall becomes necessary, a listed CHECKING FOR PROPER VENTING thimble approved for use with B-type vent must be used. Check with After completing and checking electrical, gas and vent connections, your local codes before venting through a side wall. follow the lighting instructions and allow the main burner to run for Some codes areas allow the use of existing B-type vent systems if approximately 5 minutes.
-
Page 11: Installation
INSTALLATION Battery Cover WALL SWITCH INSTALLATION 12 Volt Battery The installation of a wall switch allows you to activate the gas con- trol valve and turn the fireplace on and off. The wall switch is to be connected to the incoming 120 volt regular household wiring that supplies electricity to the fireplace. - Page 12 (see 7" Figure 21). Alternate Gas Supply Through Sub-Floor 4. Place just enough ember material to cover burner pan material. Mission36TEN Mission42TEN Leave a 1/2" space between pieces. (F0860, F0862) (F0866, F0868) Grate Vermiculite Burner Pan "...
- Page 13 INSTALLATION Continued Log 4 LOG PLACEMENT FOR MODELS MISSION36TEN (F0860, F0862) Log 3 1. Place small front right log (log 1) on right front of grate as shown in Figure 23. 2. Place large back log (log 2) onto grate making sure notches rest over grate as shown in Figure 23.
- Page 14 INSTALLATION Continued LOG PLACEMENT FOR MODELS MISSION42TEN (F0866, F0868) 1. Place large back log (log 1) onto grate making sure notches rest over grate (see Figure 27). Log 3 2. Insert lower end of log 2A between first two grate fingers and posi- Log 4 tion upper end into notch on front of log 1.
- Page 15 (see Figure 31). Pull handle to open or push to close. case, please request help if needed. CAUTION: Air inlet ducts are not to terminate in The Mission36TEN (F0860, F0862) and Mission42TEN (F0866, F0868) B-vent fireplaces are approved for use with optional bi-fold attic space.
- Page 16 INSTALLATION Continued Fold Bi-Fold Spring Clip 9. Reopen one door at a time and retighten upper and lower hold- Door After down screws. Releasing 10. Repeat process until both doors are evenly joined, spaced and Spring Clip working freely. and Slide CAUTION: The glass panels become very hot while Door Out of Press...
-
Page 17: Operation
OPERATION FOR YOUR SAFETY 14. Visually locate pilot. Igniter should begin to spark and main burner READ BEFORE LIGHTING should ignite once flame appears at pilot. • If lighting appliance for the first time each season, it may take several attempts before supply gas can reach pilot and WARNING: If you do not follow these instructions main burner. -
Page 18: Inspecting And Burner Flame Patterns
INSPECTING PILOT AND BURNER FLAME PATTERNS CLEANING AND MAINTENANCE Periodically check pilot flame pattern and burner flame patterns often. WARNING: Installation and repair should be done by a qualified service person. The appliance should PILOT ASSEMBLY be inspected before each use and at least annually The pilot assembly is factory preset for the proper flame. -
Page 19: Wiring Diagram
WIRING DIAGRAM PILOT MICRO SWITCH LIMIT SWITCH IGNITER (IF EQUIPPED) (IF EQUIPPED) BURNER ORANGE GAS VALVE TRANSFORMER BLACK WHITE BLACK BLACK BLACK HIGH VOLTAGE BLUE GROUND BLUE GREEN IGNITION MODULE WARNING: Electrical Grounding Instructions - This appliance is equipped with a three-prong 120 VAC (grounding) plug for your protection against shock hazard and should be plugged directly into a properly grounded three-prong receptacle. -
Page 20: Service Hints
SERVICE HINTS REPLACEMENT PARTS See Pages 23 to 26 for a complete replacement parts list. Use only When Gas Pressure Is Too Low parts supplied from the manufacturer. • pilot will not stay lit Normally, all parts should be ordered through your IHP distributor •... -
Page 21: Troubleshooting
TROUBLESHOOTING NOTE: Before troubleshooting the system, make sure the gas shutoff valve is ON. The two most common causes of a malfunctioning gas appliance are: 1. Loose wiring connections 2. Construction debris clogging the pilot and/or gas control valve filter OBSERVED PROBLEM POSSIBLE CAUSE REMEDY... - Page 22 TROUBLESHOOTING Continued WARNING: If you smell gas • Shut off gas supply. • Do not try to light any appliance. • Do not touch any electrical switch; do not use any phone in your building. • Immediately call your gas supplier from a neighbor’s phone. Follow the gas supplier’s instructions. •...
- Page 23 IHP. Use of non-approved parts can result in poor performance and safety hazards. LOG SETS FOR 36"MODELS LOG SETS FOR 42" MODELS MODEL CAT. NO. MODEL CAT. NO. Mission36TEN F0860 Mission42TEN F0866 F0862 F0868 CATALOG CATALOG DESCRIPTION QTY. DESCRIPTION QTY.
-
Page 24: Parts
WARNING: Contact an IHP dealer to obtain any of these parts. Never use substitute materials not approved by IHP. Use of non-approved parts can result in poor performance and safety hazards. MODEL CAT. NO. INTERIOR F0860 Mission36TEN White Stacked F0862 Mission36TEN White Herringbone F0866 Mission42TEN White Stacked F0868 Mission42TEN White Herringbone 35 34 Astria.us.com 126754-01K... - Page 25 PARTS This list contains replaceable parts used in your fireplace. When ordering parts, follow the instructions listed under Replacement Parts on Page 20 of this manual. KEY NO. CATALOG NO. DESCRIPTION MISSION36TEN MISSION42TEN QTY J6811 MICRO SWITCH • • J4305 HARNESS, WIRE ASSY.
- Page 26 PARTS WARNING: Contact an IHP dealer to obtain any of these parts. Never use substitute materials not approved by IHP. Use of non-approved parts can result in poor performance and safety hazards. Mission36 Mission36 NO. CATALOG NO. DESCRIPTION White Stacked White Herringbone QTY F3225 Refractory Set, White Herringbone...
-
Page 27: Accessories
ACCESSORIES NOTICE: All accessories may not be available for all fireplace models. CAT NO. MODEL DESCRIPTION EXTRUDED ALUMINUM BI-FOLD GLASS DOORS F0981 BD36 36" Standard Bi-Fold Glass Door - Black finish F0984 BD42 42" Standard Bi-Fold Glass Door - Black finish OPTIONAL OUTSIDE AIR KIT FOR FLOOR INSTALLATION Optional kit helps offset the negative pressure often existing in today's tightly constructed homes. - Page 28 ACCESSORIES Continued CAT NO. MODEL DESCRIPTION PERIMETER TRIM KIT F1042 PT36 36" Perimeter Trim Kit - Black F1045 PT42 42" Perimeter Trim Kit - Black PROPANE/NATURAL GAS CONVERSION KIT F1124 PCBE-36 36": Electronic Ignition - NG to LP F1125 NCBE-36 36": Electronic Ignition - LP to NG (Not Shown) F1128...
- Page 29 NOTES ______________________________________________________ ______________________________________________________ ______________________________________________________ ______________________________________________________ ______________________________________________________ ______________________________________________________ ______________________________________________________ ______________________________________________________ ______________________________________________________ ______________________________________________________ ______________________________________________________ ______________________________________________________ ______________________________________________________ ______________________________________________________ ______________________________________________________ ______________________________________________________ ______________________________________________________ ______________________________________________________ ______________________________________________________ ______________________________________________________ ______________________________________________________ ______________________________________________________ ______________________________________________________ ______________________________________________________ ______________________________________________________ ______________________________________________________ ______________________________________________________ ______________________________________________________ ______________________________________________________ ______________________________________________________ ______________________________________________________ ______________________________________________________ ______________________________________________________ ______________________________________________________ ______________________________________________________ ______________________________________________________ ______________________________________________________ 126754-01K Astria.us.com...
- Page 30 NOTES ______________________________________________________ ______________________________________________________ ______________________________________________________ ______________________________________________________ ______________________________________________________ ______________________________________________________ ______________________________________________________ ______________________________________________________ ______________________________________________________ ______________________________________________________ ______________________________________________________ ______________________________________________________ ______________________________________________________ ______________________________________________________ ______________________________________________________ ______________________________________________________ ______________________________________________________ ______________________________________________________ ______________________________________________________ ______________________________________________________ ______________________________________________________ ______________________________________________________ ______________________________________________________ ______________________________________________________ ______________________________________________________ ______________________________________________________ ______________________________________________________ ______________________________________________________ ______________________________________________________ ______________________________________________________ ______________________________________________________ ______________________________________________________ ______________________________________________________ ______________________________________________________ ______________________________________________________ ______________________________________________________ ______________________________________________________ Astria.us.com 126754-01K...
-
Page 31: Warranty
Innovative Hearth Products Astria Brand Gas Fireplace ® Limited Lifetime Warranty THE WARRANTY Innovative Hearth Products ("IHP") Limited Lifetime Warranty warrants your Astria brand gas fireplace ("Product") to be free from defects in materials and workmanship ® at the time of manufacture. The product body, firebox and barrier carry the Limited Lifetime Warranty. Ceramic glass carries the Limited Lifetime Warranty against thermal breakage only. - Page 32 Astria.us.com Record the following important information about your fireplace: Fireplace model number Fireplace serial number Date fireplace was Installed Type of gas fireplace uses Dealer name IHP reserves the right to make changes at any time, without notice, in design, materials, specifications, prices and also to discontinue colors, styles and products.
Need help?
Do you have a question about the Mission42TEN and is the answer not in the manual?
Questions and answers