Table Of Contents - ALLIANCE KEM377-1709 Service Manual

Nameplate Location ................................................ 4
Model Identification ................................................. 5
SECTION I - Grounding
1. Motor Mounting Bracket to Motor ........................ 6
2. Neutral at Terminal Block to Rear Bulkhead
and from Rear Bulkhead to Control housing ...... 7
3. Power Cord to Rear Bulkhead and from Rear
Bulkhead to Control Housing. Wall Receptacle
Polarity Check .................................................... 7
4. From Rear Bulkhead to Timer Mounting
Bracket to Dryer Cabinet Top. Timer Mounting
Bracket to Graphic Panel ................................... 8
From Rear Bulkhead to Dryer Cabinet Top
to Electronic Control to Graphic Panel ............... 8
SECTION II - Service Procedures
5. Control Hood Assembly ..................................... 9
6. Control Hood End Caps ..................................... 9
7. Electronic Control ............................................... 9
8. Timer .................................................................. 9
9. Temperature Switch ......................................... 11
o.
1 Signal Control ................................................... 11
11. Lint Filter .......................................................... 12
12. Inner and Outer Door Panels
and Door Pull ................................................... 13
13. Loading Door .................................................... 13
14. Door Strike ....................................................... 14
15. Door Seal ......................................................... 16
16. Front Panel and Panel Seal ............................. 16
17. Door Switch ...................................................... 16
18. Door Catch ....................................................... 16
D502009

Table of Contents

2
19. Door Hinge ....................................................... 18
20. Hold-Down Clips and Guide Lugs .................... 18
21. Burner System Components ............................ 19
22. Burner Housing and Heat Shroud .................... 21
23. Limit Thermostat ............................................... 21
24. Heating Element ............................................... 21
25. Thermister, Thermostat or
Thermostat and Heater .................................... 22
26. Front Air Duct ................................................... 22
27. Motor and Exhaust Assembly ........................... 23
28. Cabinet Top ...................................................... 26
29. Cylinder Light Bulb ........................................... 27
30. Cylinder Light Receptacle ................................. 27
31. Front Bulkhead Assembly ................................. 28
32. Cylinder Belt ..................................................... 29
33. Cylinder Assembly ............................................ 30
34. Rear Seal ......................................................... 31
35. Cylinder Rollers ................................................ 33
36. Outlet Cover ..................................................... 33
37. Rear Bulkhead and Heater Box Assemblies .... 33
38. Terminal Block or Power Cord ......................... 36
39. Motor Connection Block Terminals ................... 38
40. Cabinet ............................................................. 38
41. Base .•..................................•............................ 40
SECTION Ill - Adjustments
42. Leveling Legs ................................................... 41
43. Burner Flame .................................................... 42
e!
.
I
.•
-
2