Tank Draining; Draining The Recovery Tank; Draining The Solution Tank; Battery Charging - Kärcher KIRA B100 R Manual

Operations

Tank Draining

Draining The Recovery Tank

Any time scrubbing is completed, or when refilling the
solution tank, the recovery tank should be drained and
cleaned.
If the recovery tank is not drained when the
solution tank has been refilled, foam or water may
enter the float shut-off screen and cause damage to
the vacuum motor.
1. While holding the recovery tank drain hose
upward, remove the cap and lower hose to drain.
2. Open the Recovery tank cover and rinse out the
tank. Use a rag to remove any excess dirt. Clean
the vacuum fan inlet filter located in the recovery
tank.

Draining The Solution Tank

Any time scrubbing operation is completed, the solution
tank should be drained and cleaned.
1. While holding the solution tank drain hose upward,
remove the cap and lower hose to drain.
2. Rinse the solution tank with clean water after every
use. This will help prevent chemical buildup and
clogging of the solution lines.
18
'
8.645-040.0 Operator Manual KIRA B100 R

Battery Charging

Fire or explosion hazard. Batteries emit hydrogen
gas. Keep sparks and open flame away. Keep
battery compartment propped open when charging.

External Charger

Use a 24V 50A DC charger which will automatically
shut off when the batteries are fully charged.
1. Stop the machine in a clean, well ventilated area
next to the charger.
2. Turn "OFF" machine.
FOR SAFETY: Before leaving or servicing machine;
stop on level surface, turn off machine and remove
key.
3. Lift seat.
FOR SAFETY: When charging, connect the charger
to the batteries before connecting the charger to
the AC wall outlet. Never connect the charger to the
AC wall outlet first. Hazardous sparks may result.
4. Plug the charger connector into the battery
connector. Connect the charger AC plug to a wall
outlet. The charger gauge should indicate that the
batteries are charging.
5. When the batteries are fully charged, disconnect
the charger from the AC wall outlet, then discon-
nect the charger from the batteries.
6. Lower seat.
'