Installation; All Models; Grcd Models - Hatco Glo-Ray GRCD-1P Installation & Operating Manual

ALL MODELS

!
CAUTION
The National Sanitation Foundation (NSF) requires
units over 36" (914 mm) in length or weighing more
than 80 lbs. (36 kg) to be either sealed or raised
on the installation surface. If this unit cannot
be sealed at the point of use, 4" (102 mm) legs
are included to allow for proper cleaning access
below unit.
CAUTION
To avoid damage to glass do not remove rubber
shipping tabs or tape from glass until legs have
been installed.

GRCD MODELS

1. Remove plastic bag containing 4 adjustable legs
from inside the unit.
2. Remove pan rail (GRCD units) or pan skirts, water
trough (GRCDH units) and front glass.
3. Carefully lay unit on its side (requires 2 people).
Install legs to bottom of unit as shown in Figure 8.
Hand tighten legs until snug. Do not overtighten.
Return unit to the upright position.
CAUTION
Do not lay unit on the side with the control panel
or the front of a curved glass unit, damage to unit
could occur.
NOTE: Legs are adjustable for leveling the unit. Use
a 9/16" (14 mm) open-end wrench to make leveling
adjustments once the unit is placed in final position.
4. Remove rear doors on 2-pan and 3-pan models
by grasping the door edges then lifting up
and out of the bottom channel. Discard
the protective cardboard from top of each door.
NOTE: Do not remove the plastic glides from top
of door glass. See Figure 9.
5. Remove tape and protective film from all outside
surfaces of unit.
6. Remove front curved glass by rotating it partially
forward and lifting straight up and off. Discard
rubber packing strips.
7. Remove tape and protective film from all internal
parts and surfaces.
8. Install pan rail (GRCD units) or pan skirts and water
trough (GRCDH units).
9. Install rear doors and front curved glass.
Leg Adjustment
Adjust leg using a 9/16"
(14 mm) open-end
wrench and turning
bottom of leg
accordingly.
Figure 8. Adjustable Legs
Left Rear Door*
Pan Rail (GRCD models)
* 1-Pan models have a hinged door.
Figure 9. Exploded View - GRCD Models
11

INSTALLATION

Leg Installation
Right Rear Door*
Door Glides
(2 ea. door)
Front Curved Glass
Pan Divider
(GRCDH models)
Water Trough
(GRCDH models)
Pan Skirt
(GRCDH models)
Form No. GRCD/HDM-0703