Club Car CARRYALL 502 ELECTRIC Operator's Manual page 16

Safety Information
1
Vehicle Safety Information
OPERATING INSTRUCTIONS
Before using vehicle, read owner's manual and vehicle safety warnings.
Study and understand controls.
TO OPERATE
• Ensure wheels are turned in desired direction of travel and path is
clear.
• Turn key to ON.
• Set the FNR control to FORWARD (F) or REVERSE (R) only when
stopped.
• Disengage the park brake.
• Vehicle will start moving when accelerator pedal is pushed.
• Slowly push the accelerator pedal to increase speed.
• During operation, a beeping alarm indicates a reduction in
regenerative braking.
• To stop, release accelerator pedal and push the brake pedal.
! WARNING
UNINTENDED VEHICLE MOVEMENT CAN CAUSE SERIOUS
INJURY OR DEATH
Before leaving vehicle:
• Engage park brake to lock wheels.
• Set the FNR control to NEUTRAL (N).
• Turn the key to OFF and remove key.
5. Operating Instructions Decal
WARNING
FALLING OFF CAN CAUSE
SERIOUS INJURY OR DEATH
Do not ride in the cargo bed.
7. Bed Loading Warning Decal
WARNING
FIRE CAN CAUSE SERIOUS INJURY OR DEATH
• Replacement battery wires must be 4-gauge (AWG) with low-resistance terminals
equivalent to factory-installed wires.
• Clean and tighten battery connections. Refer to the owner's manual.
9. 4-Gauge Wire Warning Decal
CAUTION
Frame is isolated from
power system. Do not
use as ground.
11. Ground Warning Decal
Page 14
101553901
105124701
WARNING
!
CRUSH AREA
STAY CLEAR
101609401
6. Crush Area Warning Decal
WARNING
CRUSH AREA STAY CLEAR
Do not lift bed with cargo inside.
Remove cargo before bed lift.
Lift bed only for maintenance and service.
Maximum cargo of 300 lb (140 kg) in bed.
8. Slim Bed Box Only: Slim Bed Box Warning
Decal
CAUTION
!
EXPOSURE TO WATER CAN
DAMAGE ELECTRONIC COMPONENTS
• Do not operate the vehicle without this cover correctly installed.
• Do not direct a water stream in the area of the cover without
the cover securely in place.
• Read and understand the maintenance and service manual
before servicing.
10. Component Cover Decal
(+) 48V ACC.
FUSE BLOCK
12. 48-Volt Accessory Fuse Block Decal
TPCC01DQ00EN019 (Edition C)
47706024001_A
102518301
105130001
CARRYALL 502 ELECTRIC
Operators Manual