Club Car CARRYALL 502 ELECTRIC Operator's Manual page 60

Vehicle Maintenance
8
Vehicle Maintenance Hazard Statements
DANGER
WARNING
Page 58
INCORRECT OPERATION OF THE CARGO BED CAN CAUSE
SERIOUS PERSONAL INJURY OR DEATH. KEEP ALL PERSONS
CLEAR OF THE CARGO BED AREA WHEN THE CARGO BED IS
LIFTED, LOWERED, OR DURING MAINTENANCE. KEEP HANDS
CLEAR OF ALL CRUSH AREAS. DO NOT LET THE CARGO BED FALL.
BEFORE THE CARGO BED IS LIFTED, REMOVE ALL CARGO AND
ACCESSORIES FROM THE CARGO BED. CORRECTLY ENGAGE THE
PROP ROD. CAREFULLY LOWER THE CARGO BED.
A WHEEL OR TIRE THAT HAS DAMAGE CAN CAUSE PROPERTY
DAMAGE, SERIOUS PERSONAL INJURY, OR DEATH. DO NOT TRY
TO REPAIR A WHEEL OR TIRE. SPEAK WITH YOUR LOCAL DEALER
OR DISTRIBUTOR FOR REPAIRS.
UNINTENDED VEHICLE OPERATION CAN CAUSE SERIOUS
PERSONAL INJURY OR DEATH. BEFORE LEAVING THE VEHICLE
OR DURING VEHICLE MAINTENANCE, DISABLE THE VEHICLE.
ONLY TRAINED TECHNICIANS SHOULD SERVICE OR REPAIR THE
VEHICLE. ANYONE DOING EVEN SIMPLE REPAIRS OR SERVICE
SHOULD HAVE KNOWLEDGE AND EXPERIENCE IN ELECTRICAL
AND MECHANICAL REPAIR. THE APPROPRIATE INSTRUCTIONS
MUST BE USED WHEN PERFORMING MAINTENANCE, SERVICE, OR
ACCESSORY INSTALLATION.
FAILURE TO CORRECTLY MAINTAIN THE VEHICLE AND MAKE
NECESSARY REPAIRS CAN DECREASE VEHICLE PERFORMANCE,
CAUSE A FIRE, PROPERTY DAMAGE, SERIOUS PERSONAL
INJURY, OR DEATH. IF PROBLEMS ARE FOUND DURING
SCHEDULED INSPECTION OR SERVICE, OPERATE THE VEHICLE
ONLY WHEN REPAIRS ARE MADE.
UNINTENTIONAL VEHICLE STARTUP CAN CAUSE A FIRE,
PROPERTY DAMAGE, OR SERIOUS PERSONAL INJURY. SET THE
RUN/TOW SWITCH TO TOW. DISCONNECT THE BATTERIES.
WAIT 90 SECONDS FOR THE CONTROLLER DISCHARGE.
DO NOT WORK ON THE VEHICLE POWERTRAIN WHEN THE
VEHICLE IS LOADED.
ELECTRICAL SHORTS CAN CAUSE A FIRE, ELECTRICAL SHOCK,
SERIOUS PERSONAL INJURY, OR DEATH. PREVENT CONTACT
BETWEEN POSITIVE VOLTAGE AND THE GROUND CIRCUIT. USE
INSULATED TOOLS.
DO NOT WEAR LOOSE CLOTHING OR JEWELRY SUCH AS RINGS,
WATCHES, CHAINS, ETC., WHEN SERVICING THE VEHICLE OR
BATTERY CHARGER.
DO NOT WORK ON VEHICLE POWERTRAIN OR UNDER THE CARGO
BED WHEN IT IS LOADED.
LIFT ONLY ONE END OF THE VEHICLE AT A TIME. USE A SUITABLE
LIFTING DEVICE WITH 1000 LB (454 KG) MINIMUM LIFTING
CAPACITY. DO NOT USE THE LIFTING DEVICE TO HOLD THE
VEHICLE IN THE LIFTED POSITION. USE APPROVED JACK
STANDS OF PROPER WEIGHT CAPACITY TO SUPPORT THE
VEHICLE AND CHOCK THE WHEELS THAT REMAIN ON THE FLOOR.
CARRYALL 502 ELECTRIC
Operators Manual
TPCC01DQ00EN019 (Edition C)