Table of Contents
Advertisement
EVERY 1000 SERVICE HOURS OR ONCE A
YEAR
BReplacing Air Filter Element
Open the engine hood and remove the dust-cover.
Remove and replace the outer element and inner element
with new elements.
When reassembling, install the dust-cover so that its TOP
mark (arrow) faces up-wards.
(1) Inner element
(2) Outer element
(3) Dust-cover
(4) Clamps
A Shorten the replacement period if the machine is used
in dusty or sandy areas.
EVERY 1500 SERVICE HOURS
BChecking Fuel Injection Nozzle (Injection
Pressure)
Consult your local KUBOTA dealer for this service.
EVERY 2000 SERVICE HOURS
Do all 50, 100, 200, 250, 500 and 1000 hour servicing at
the same time.
BChanging Front Idler and Track Roller Oil
A Contact your KUBOTA dealer for details.
BChecking the Alternator and Starter Motor
A Contact your KUBOTA dealer for details.
EVERY 3000 SERVICE HOURS
BChecking Injection Pump
Consult your local KUBOTA dealer for this service.
REGULAR CHECKS AND MAINTENANCE WORK
ANNUAL SERVICING
BElectrical Wiring and Fuses
Check the terminals periodically for proper connections.
Loose wiring or damaged cables can cause improper
functioning or short circuiting of the electrical system.
Check wiring and replace damaged components
immediately. If a fuse blows out soon after having been
replaced, contact your nearest KUBOTA dealer. Never
use a fuse other than specified.
BChecking the Electrical Circuit
Check the electrical circuitry for disconnections, shorts or
loose terminals.
BChecking Air-Conditioner Pipes and
Hoses
To avoid personal injury or death:
A Do not touch the coolant hoses or the heater
with your hand. You may get burned.
1. Check to see that all lines and hose clamps are tight
and not damaged.
2. If hoses and clamps are found worn or damaged,
replace or repair them at once. (Consult your local
KUBOTA dealer for this service.)
BIENNIAL SERVICING
To avoid personal injury or death:
A Do not loosen the radiator cap before the
radiator has cooled down sufficiently. Only
loosen the cap after allowing enough time for
the pressure in the system to be reduced.
Thereafter, one can remove the cap completely.
BReplacing Air-Conditioner Pipes and
Hoses
To avoid personal injury or death:
A Do not touch the coolant hoses or the heater
with your hand. You may get burned.
Replace air-conditioner pipes and hoses every two years.
If the hoses or pipes are swollen, hard or cracked, they
must be replaced earlier. (Consult your local KUBOTA
Dealer for this service.)
75
Advertisement
Table of Contents
