Conti CC100 Series Technical Documentation Manual
  1. Manuals
  2. Brands
  3. Conti Manuals
  4. Coffee Maker
  5. CC100
  6. Technical documentation manual

Conti CC100 Series Technical Documentation Manual

Hide thumbs Also See for CC100 Series:

Advertisement

Table of Contents

CC100+
TECHNICAL DOCUMENTATION
Edition 05/2021
SACOME, Document CONFIDENTIEL, Ne peut être reproduit ni communiqué sans notre accord préalable.

Advertisement

Table of Contents
loading

Related Manuals for Conti CC100 Series

Summary of Contents for Conti CC100 Series

  • Page 1 CC100+ TECHNICAL DOCUMENTATION Edition 05/2021 SACOME, Document CONFIDENTIEL, Ne peut être reproduit ni communiqué sans notre accord préalable.

  • Page 2: Table Of Contents

    Index __________________________________________________________ Page TECHNICAL DOCUMENTS _______________________________________________________________ 2 DIMENSIONS _________________________________________________________________________ 2 CAUTION DURING THE USE ______________________________________________________________ 3 INSTALLATION _______________________________________________________________________ 5 OPERATION _________________________________________________________________________ 7 HOW TO USE THE MACHINE _____________________________________________________________ 8 PROGRAMMING OF COFFEE DOSAGE _____________________________________________________ 10 RELATED FONCTIONS _________________________________________________________________ 11 PROGRAMMING THE MACHINE __________________________________________________________ 12 10.

  • Page 3: Technical Documents

    1. TECHNICAL DOCUMENTS INSTALLED ELECTRICAL TYPE HEATING POWER CONSUMPTION MACHINE POWER With 230V (A) CC101 i 2500 2700 CC102 i 3300 3600 CC103 i 4700 5000 CC103 i Tri 6000 6300 10A / phase BOILER CAPACITY ( LITERS) TOTAL VOLUME OF HOT WATER VOLUME OF STEAM WEIGHT empty WEIGHT...

  • Page 4: Caution During The Use

    3. CAUTION DURING THE USE 3.1. USE CONDITIONS This appliance can be used by children aged from 8 years and above and persons with reduced physical, ➢ sensory or mental capabilities or lack of experience and knowledge if they have been given supervision or instruction concerning use of the appliance in a safe way and understand the hazards involved;...
  • Page 5 3.3. DURING INSTALLATION The installation (electrical connections, water supply and drainage) must be carried out by a qualified ➢ technician approved by CONTI. The machine must be connected to a device conforming to the standards of the country where the ➢...

  • Page 6: Installation

    4. INSTALLATION 4.1. IN CASE OF A STANDBY OF THE MACHINE (STANDBY = 2 MONTHS): The first thing to do is to test your machine in a lab. ➢ If the machine stop ruming for a long time, you could have scale in some places. ➢...
  • Page 7 4.6. WATER SOFTENER When the mains water has a high hardness (>10°TH ou >4 °KH), it is recommanded: ➢ To use a water treatment To regenarate regularly the filters. What is the total Hardness of the water ? ➢ This is the amount of calcium and magnesium ions in the water. These ions are partly responsible for limestone formation.

  • Page 8: Operation

    5. OPERATION 5.1. RECOMMANDATIONS Open the general water tap, if it is closed, then open the water shutoff valve dedicated to the ➢ machine. Do not put the supplying voltage at this moment. ➢ Verify the presence of water, by reading the pressure of the mains water inlet on the M2 manometer ➢...

  • Page 9: How To Use The Machine

    6. HOW TO USE THE MACHINE 6.1. OPERATING ELEMENTS STEAM FUNCTION ➢ Two steams taps levers « V » are provided to allows: • The heating of liquids by spraying steam. • The milk foam production to create Cappuccino or Macchiatto. The liquid to be heated should preferably be placed in a deep container.
  • Page 10 MANOMETER M1 : BOILER PRESSURE ➢ The boiler pressure is adjusted in factory between 0,08 MPa (12 PSI) and 0,1 MPa (15 PSI). This value varies slightly around its nominal temperature, due to the PID system which controls the heating and limit the current consumption to its minimum.

  • Page 11: Programming Of Coffee Dosage

    7. PROGRAMMING OF COFFEE DOSAGE 7.1. PROGRAMMING PROCEDURES Programming is done on the group 1 (left group), the 5 keys are defined as follows: P1 Gr1 P2 Gr1 P3 Gr1 P4 Gr1 P5 Gr1 1shot 2shots 1regular 2regular continuous espresso espresso coffee coffee...

  • Page 12: Related Fonctions

    • Insert blind filter (provided with the machine) in the filter-holder. • Put a detergent tablet (CONTI brand code: 466662) in the blind filter, and engage the filter-holder in the group. • Keep pressing key n°5 (P5 Gr1), then press the key n°1 (P1 Gr1).

  • Page 13: Programming The Machine

    9. PROGRAMMING THE MACHINE 9.1. PROGRAMMING OF PRE-BREWING (1SEC ON / 1SEC OFF) The pre-brewing is only available on Espresso (1 or 2 shots). The pre-brewing is adjusted by default on these 2 buttons, if the user wants to delete it, he needs to do as follows: Settings without pre-brewing: ➢...
  • Page 14 9.3. PROGRAMMING THE FILLING UP THE BOILER WITH THE PUMP If the machine is connected to a water network, it is not necessary to use the pump for filling the boiler (minimum inlet pressure 0,15 MPa). If the machine is connected to a water tank, to fill the boiler you have to activate the pump. The machine is configured by default "without pump"...

  • Page 15: Description Of Alarms

    10. DESCRIPTION OF ALARMS These alarms occur when there is a defect on the machine, they are indicated differently depending on the nature of the defect. ALARM TIME OUT 1ST FILLING ➢ If the electronic does not receive information from the SN level probe for more than 360 seconds (at the 1st filling), the LED "L2"...

  • Page 16: How To Make The Perfect Coffee

    11. HOW TO MAKE THE PERFECT COFFEE Obtaining a good cup of coffee is the result of certain conditions: the 5 golden rules of perfect espresso: MIX / GRINDER / MACHINE / HAND / and MAINTENANCE. The Mix: ➢ The type of coffee is very important. It can be distinguished 2 mains qualities: ARABICA: ▪...
  • Page 17 The Hand: ➢ Skill of the operator: He must of course control the above three factors, but also: ➢ He know how to maintain coffee. o For exemple, a milling do not remain in the open air. o He know that coffee bean loses 1% of its flavor by day ground coffee, it loses 45% day. o Therefore he avoid grinding too much coffee at once, or keep in drawers.

  • Page 18: Maintenance Of Machines

    Remove the filter-holder from the groups and clean the seal injection filter-holder with the brush. Use the automatic process cleaning: Insert blind filter in the filter holder and place the CONTI cleaning tablet code n°466662 Engage this filter-holder on the group to be cleaned...
  • Page 19 ANNUAL MAINTENANCE ➢ A kit n° 470892, for the following operation is available for sale. Change the pump inlet filter (No. 411861) On the boiler: Change vaccum valve (No. 408898) Change the safety valve (No. 404326) On the inlet bloc valves: Change the filter (No.
  • Page 20 BIENNiAL ENTRETIEN ➢ A kit n° 470892, for the following operation is available for sale. Change the pump inlet filter (No. 411861) On the boiler: Change vaccum valve (No. 408898) Change the safety valve (No. 404326) On the inlet bloc valves: Change the filter (No.

  • Page 21: Electronic Diagram

    13. ELECTRONIC DIAGRAM 13.1. DESIGNATION OF USEFUL CODES REF. DESIGNATIONS DESIGNATION Carte électronique Electronic controller Connecteur tableau Panels connector Compteur volumétrique Flow meter EV entrée eau Solenoid valve water feeding EV de groupe Group solenoid valve Motopompe Motor/pump Résistance chauffage Immersion heater Relais statique 12Vdc - 230Vac 25A Solid state relay 12Vdc - 230Vac 25A...
  • Page 22 13.2. ELECTRICAL HEATING CIRCUIT FOR CC100 1G (2500W) & 2G (3300W) 230V 50/60HZ Edition 05/2021 - CC100+ - technical documentation - page 21 SACOME, CONFIDENTIAL Document, it is forbidden to duplicate or communicate this document without previous authorization.
  • Page 23 13.3. ELECTRICAL HEATING CIRCUIT Edition 05/2021 - CC100+ - technical documentation - page 22 SACOME, CONFIDENTIAL Document, it is forbidden to duplicate or communicate this document without previous authorization.
  • Page 24 13.4. ELECTRICAL HEATING CIRCUIT Edition 05/2021 - CC100+ - technical documentation - page 23 SACOME, CONFIDENTIAL Document, it is forbidden to duplicate or communicate this document without previous authorization.

  • Page 25: Hydraulic Schema

    14. HYDRAULIC SCHEMA Edition 05/2021 - CC100+ - technical documentation - page 24 SACOME, CONFIDENTIAL Document, it is forbidden to duplicate or communicate this document without previous authorization.

  • Page 26: Option Available

    15. OPTION AVAILABLE 15.1. SOLO KIT In case of insufficient pressure on the water system, or if the water supply is non-existent, you must use separate water tanks. The machine must operates in SOLO mode: The filling up must be parametered "WITH PUMP" (P1 + P4) ➢...
  • Page 27 Edition 05/2021 - CC100+ - technical documentation - page 26 SACOME, CONFIDENTIAL Document, it is forbidden to duplicate or communicate this document without previous authorization.
  • Page 28 S a c o m e , L a R u c h e , 1 A v e n u e A l b e r t I I , B . P . 1 1 9 9 8 0 0 7 M o n a c o C e d e x E-mail: conti@conti-espresso.com Tél : +377 93 10 43 43 Fax : +377 93 10 43 44...

This manual is also suitable for:

Cc101 iCc102 iCc103 iCc103 i tri

Table of Contents