Table of Contents
Advertisement
Quick Links
Advertisement
Table of Contents
Related Manuals for Cal Flame LTR20081044
Summary of Contents for Cal Flame LTR20081044
- Page 1 LTR20081044, Rev. A 4/21/08...
-
Page 2: Table Of Contents
Copyright 2008 Lloyds Material Supply, Inc. All rights re- served. Duplication without written consent is strictly pro- hibited. Cal Spas™ and Cal Flame™ are registered trademarks. Due to continuous improvement programs, all models, op- eration, and/or specifications are subject to change without prior notice. -
Page 3: Safety Instructions
There is an area on the back cover of this manual where you can write down this information. • Your Cal Flame™ grill must be plugged into a per- manent, grounded 220V outlet with a dedicated 15A RCD breaker. •... -
Page 4: Maintenance And Repair
Unless specifically recommended in this manual, do not repair or replace any part of the grill. A qualified technician should perform all service. Any repairs made by a non-Cal Flame approved dealer techni- cian will void your warranty. Storage •... -
Page 5: Installation / Assembly
LP will be marked on the operating tab, indicating the proper operating fuel. Attempting to convert Cal Flame™ grills from one fuel to another may result in serious injury and will void the warranty coverage. -
Page 6: Leak Testing Procedure
LP gas. Maximum line pressure for plumbed-in propane is 14” WC (3.5 kPa). Minimum line pressure for propane is 11” WC. Cut-out for drop in accessories DEPTH WIDTH HEIGHT Cal Flame 2008 Owner’s Manual LTR20081044, Rev. A... -
Page 7: Installing The Transformer
7.1 cm²/kg (one square inch per pound) of stored fuel capacity and not less than a to- Cal Flame 2008 Owner’s Manual LTR20081044, Rev. A Installation / Assembly tal free area of 64.5cm²... -
Page 8: Installing Grills In Barbecue Islands
Attach the metal plate to the outside surface of the grill as shown in the figure below. When you have firmly tightened the screws and nuts, connect the plug from the transformer to the grill. Screw on the stainless steel retainer. Installing Grills in Barbecue Islands Page 6 Cal Flame 2008 Owner’s Manual LTR20081044, Rev. A... -
Page 9: Installing The Rotisserie
Perform the leak test procedure as described earlier in this manual. Cal Flame 2008 Owner’s Manual LTR20081044, Rev. A Installation / Assembly Installing the Rotisserie Attach the two brackets to the sides of the grill, one on each side, using two screws as shown below. -
Page 10: Installing Side Burners
(Use gas rated tape seal on all connections). Connect the last open line to the side burner. (Use gas rated tape seal on all connections) Cal Flame 2008 Owner’s Manual LTR20081044, Rev. A... -
Page 11: Operating Your Barbecue
Do not use charcoal in a gas grill or side burner or electric grill. Grill Controls The controls shown at right are for Cal Flame™ drop-in grills. Familiarize yourself with these controls before using your Cal Flame™ barbecue. Infrared Burner... -
Page 12: Lighting The Grill
Inspect the hose before using the grill. If there is excessive abrasion or wear, or if the hose is cut, it must be replaced prior to using the grill. If you need a replacement hose, contact your Cal Flame dealer. •... -
Page 13: Basic Grill Operation
(never use nylon or plastic string). Place a basting pan under the food to collect the drippings. Cal Flame 2008 Owner’s Manual LTR20081044, Rev. A Operating Your Barbecue Turn the control knob to HIGH and preheat the grill for 15 minutes. -
Page 14: Cooking With A Side Burner
The ON / OFF switch controlling your halogen light is located at the control panel on the front lower left side. Certain models of the Cal Flame grill are equipped with either one or two halogen light. Your grill must be plugged into a permanent grounded 220 VAC outlet with a dedicated 15A RCD breaker. -
Page 15: Cleaning And Maintenance
When not in use and after cooling, cover your grill with our full length, zippered side canvas cover. (See your local Cal Flame dealer for details.) The cover will help protect your grill from detrimental effects of weather and environmental pollutants. Never put a cover on a hot grill. -
Page 16: Light Bulb Replacement
Tighten the two screws on the side white ceramic light fixture. Carefully replace the light cover by snapping it in place. Page 14 Cal Flame 2008 Owner’s Manual LTR20081044, Rev. A... -
Page 17: Appendix
If the flame is golden or yellow in color, the reason could be seasoning salts, oil film, or other foreign matter on the burner. Cal Flame 2008 Owner’s Manual LTR20081044, Rev. A... - Page 18 • Replace all cotter pins. • Replace cooking components and grease collectors. If an obstruction is suspected in the control valve, contact your local Cal Flame dealer for assis- tance. Problem: Misalignment of Igniter on Burner Solution: •...
-
Page 19: Removing And Replacing Infrared Burners
4 burner grill 5 burner grill 2 burner / 3 burner cart 4 burner cart Cal Flame 2008 Owner’s Manual LTR20081044, Rev. A Carefully remove the locking pin with your fingers. Raise the stud from the locking hole and move the burner forward carefully to release it from the igni- tion and gas supply valve. -
Page 20: Location Of Serial Number Plate
BBQ08CR5000DSCU Five burner convection cart with double side burner Location of Serial Number Plate The serial number of your Cal Flame grill is located on the back and is visible when the hood is down as shown at right. BE, CY, CZ, EE, FR, GR, IE, IT, LV,...