Save these instructions! Copyright 2008-2009 LMS, Inc. All rights reserved. Duplication consent is strictly prohibited. Cal Flame ® is a registered trademark. Due to continuous improvement programs, all models, operation, and/or specifications are subject to change without prior notice. LTR20091050, Rev. A...
Do not place this grill under or near windows or vents that can be opened into your home. • Cal Flame grills are not intended for installation in or on recreational vehicles or boats. • Maintain sufficient distance as to not overheat any overhead combustible material such as a patio cover.
Page 4
Never allow clothing, pot holders or other flammable materials come in contact with or be close to any grate, burner or hot surface until it has fully cooled. Never wear loose fitting or hanging www.calspas.com er than intended use. 2009 G3, G4, G5 Grills LTR20091050, Rev. A...
Any repairs made by a non-LMS approved dealer technician will void your warranty. Storage • When your gas grill is not in use, turn off the gas at the supply cylinder. • Storage of a grill indoors is permissible only if the supply is disconnected and removed.
If you do not have an updated filler valve on your existing propane tank, you will need to purchase one at your local hardware store. Without it you will not be able to attach your tank to your Cal Flame grill or refill the tank at your local propane refill station.
Cabinet Cut-out Dimensions Your Cal Flame grill is designed for easy installation into a non- combustible enclosure. The supporting deck or counter must be flat and level. When determining the final location of your grill, adequate cross ventilation must be present to prevent gas from being trapped in the event of a leak.
National Standard of Canada, CAN/CSA-B339, Cylinders, Spheres and Tubes for Transportation of Dangerous Goods; and Commission, as applicable. • Approximately 12 inches in diameter and 18 inches high. www.calspas.com Specifications 2009 G3, G4, G5 Grills LTR20091050, Rev. A...
Page 9
Store cylinders outdoors and out of reach of children. Do not store cylinders in a building, garage, or any other enclosed area. 2009 G3, G4, G5 Grills LTR20091050, Rev. A www.calspas.com...
0.5 psi (3.5 kPa). Your Cal Flame grill for use with natural gas comes equipped with its own regulator that MUST NOT be removed. If this regulator needs to be replaced, use only the type specified by Cal Flame for this appliance.
On LP systems, remove the cylinder from the grill. Call an authorized gas appliance service technician or an LP gas dealer. Do not use the appliance until the leak is corrected. 2009 G3, G4, G5 Grills LTR20091050, Rev. A www.calspas.com...
If the grill is not level or is unstable, use non- combustible shims under the outside lip to stabilize it. Perform the leak test procedure as described earlier in this manual. www.calspas.com 2009 G3, G4, G5 Grills LTR20091050, Rev. A...
CAUTION: NEVER spray water on a hot gas unit. This may damage porcelain or cast iron components. Grill Controls The controls shown below are for the G4 grill. Familiarize yourself with these controls before using your Cal Flame barbecue. Burners 2009 G3, G4, G5 Grills LTR20091050, Rev. A your grill.
• Ensure the propane cylinder, regulator, and rubber hose are installed in a location not subject to heating above 125º F (51º C). www.calspas.com 2009 G3, G4, G5 Grills LTR20091050, Rev. A...
Inspect the hose before using the grill. If there is excessive abrasion or wear, or if the hose is cut, it must be replaced prior to using the grill. If you need a replacement hose, contact your Cal Flame dealer.
Shut off gas to the appliance. • Extinguish any open flame. • Open lid. • If odor continues, keep away from the appliance and immediately call your gas supplier or your fire department. www.calspas.com DANGER 2009 G3, G4, G5 Grills LTR20091050, Rev. A...
Do not obstruct the flow of combustion and ventilation air. If your LP-gas grill is placed in a stationary barbecue island, keep the access door for the propane cylinder clear of any obstruction. Ensure the ventilation opening for cylinder enclosure is kept clear.
Covering Your Grill When not in use and after cooling, cover your grill with our full length, zippered side canvas cover. (See your local Cal Flame dealer for details.) The cover will help protect your grill from detrimental effects of weather and environmental pollutants. Never put a cover on a hot grill.
Make sure the valve orifice is aligned inside the front hole of the burner. • If there is no spark at all, replace the electrode or igniter wire. Note: Turn troubleshooting. 2009 G3, G4, G5 Grills LTR20091050, Rev. A source while www.calspas.com...
Page 20
• • • • If an obstruction is suspected in the control valve, contact your local Cal Flame dealer for assistance. Problem: Burner tube is misaligned over the orifice Solution: Reposition the burner tube so that it is properly seated over the orifice.
Page 21
‘OFF’ position. Wait until the grill has cooled off and then clean the burner tubes and burners as described on page of this manual. 2009 G3, G4, G5 Grills LTR20091050, Rev. A www.calspas.com...
Take the burner out of the grill and store it in a safe and dry place. www.calspas.com COVER, GRILL, MEDIUM, 3 BURNER COVER, GRILL, MEDIUM, 4 BURNER COVER, GRILL, MEDIUM, 3 BURNER 2009 G3, G4, G5 Grills LTR20091050, Rev. A...
2009 Warranty LMS warrants the G3, G4, and G5 grill and associated hardware from defects in material and workmanship for a period of one year from the original date of purchase. One Year Equipment and Component Warranty LMS warrants against deterioration and corrosion •...
Page 24
This Limited Warranty applies only to barbecue grills normally used for personal, family, or household purposes and specifically excludes commercial use of the barbecue grill. www.calspas.com 2009 G3, G4, G5 Grills LTR20091050, Rev. A...
LMS Customer Relations Department at 1462 E. Ninth St., Pomona CA 91766 or call (800) 225-7727. See your Cal Flame barbecue dealer for a copy of the applicable warranty, details and any questions you may have regarding the warranty coverage on your barbecue.
LMS Customer Service Department 1462 East Ninth Street Pomona, CA 91766 Toll Free: 1-800-CAL-SPAS Fax: 1-909-629-3890 www.calspas.com LTR20091050, Rev. A 12/11/08...