Table of Contents
Advertisement
Quick Links
Advertisement
Table of Contents
Related Manuals for Cal Flame BBQ845P
Summary of Contents for Cal Flame BBQ845P
- Page 1 LTR20081050, Rev. A 6/2/08...
-
Page 2: Table Of Contents
Using Your Grill . . . . . . . . . . . . . . . . . . . -
Page 3: Safety Instructions
In the event that a burner goes out, turn burner knobs to the full OFF position, fully open the grill hood and let it air out. Do not attempt to use the grill until the gas has had time to dissipate. -
Page 4: Precautions Regarding Children
Storage • When your gas grill is not in use, turn off the gas at the supply cylinder. • Storage of a grill indoors is permissible only if the supply cylinder is disconnected and removed. -
Page 5: Installation / Assembly
Without it you will not be able to attach your tank to your Cal Flame™ grill or refill the tank at your local propane refill station. -
Page 6: Leak Testing Procedure
LP gas dealer. Do not use the appliance until the leak is corrected. The grill unit must be used with the gas pressure regula- tor. The regulator will control and maintain a uniform gas pressure in the manifold. The burner orifices have been sized for the gas pressure delivered by the regulator. -
Page 7: Natural Gas
Natural Gas Requirements Always check the rating plate to make sure the gas supply you are hooking up to is the gas type the grill is manufactured for. IMPORTANT: Never connect the grill to an unregulated gas supply. The installation of this appliance must conform with lo- cal codes or, in the absence of local codes, to the na- tional fuel gas code, ANSI Z223.1a-1998. -
Page 8: Installing The Grill In A Barbecue Island
Before installing a grill in any island or cut out, make sure that the opening is not bigger than the outside frame of the grill unit. The grill should rest on the lip of the frame. Pay careful attention to the location of the gas line. It should be routed away from sources of heat and should make as few bends as possible. -
Page 9: Using Your Grill
Grill Knob Operation Warning NEVER cover the entire cooking or grill surface with griddles or pans. Overheating will occur and burners will not perform properly when combustion heat is trapped below the cooking surface. CAUTION: NEVER spray water on a hot gas unit. This may damage porcelain or cast iron components. -
Page 10: Lighting The Grill
Inspect the hose before using the grill. If there is excessive abrasion or wear, or if the hose is cut, it must be replaced prior to using the grill. If you need a replacement hose, contact your Cal Flame dealer. -
Page 11: Cleaning And Maintenance
“flashback”. To reduce the risk of flash- back, this procedure should be followed at least once a month or when your grill has not been used for an extended period of time. IMPORTANT: Prior to starting this procedure, turn OFF all of the gas control knobs, shut off the fuel supply, and disconnect the fuel line. -
Page 12: Appendix
Problem: Obstruction in the gas line Solution: Remove the fuel line from grill. (Do not smoke or perform any maintenance in the vicinity of an open flame.) Open the gas valve for one second to blow out any debris. Close off the gas valve and recon- nect the fuel line securely. -
Page 13: Replacement Covers
Solution: When fire occurs in and around the burner tubes, immediately turn off gas at its source and turn the control knob(s) clockwise to the ‘OFF’ position. Wait until the grill has cooled off and then clean the burner tubes and burners as described on page of this manual. -
Page 14: Removing And Replacing Burners
Raise the stud from the locking hole and move the burner forward carefully to release it from the igni- tion and gas supply valve. Take the burner out of the grill and store it in a safe and dry place. 2008 Barbecue Grill and Cart Owner’s Manual... -
Page 15: 2008 Warranty
L.M.S.’s representatives. Warranty Limitations This warranty is void if the barbecue grill has been subject to negligence, alteration, misuse, repairs, dings, dents, scratches, or incorrect and / or prohibited applications, as specified in the owner’s manual. Gas lines must be in- stalled by a licensed plumber only or local gas company agent. -
Page 16: Warranty Limitations
Locating the product serial number The serial number of your Cal Flame grill is located on the back and is visible when the hood is down. You will need this number to properly register your grill and activate coverage. Write this information in the space provided below.
Need help?
Do you have a question about the BBQ845P and is the answer not in the manual?
Questions and answers