Generac Power Systems 0058330 Installation Manuallines page 4


GENERAL HAZARDS
• For safety reasons, the manufacturer recommends that this
equipment be installed, serviced and repaired by a Service Dealer
or other competent, qualified electrician or installation technician
who is familiar with applicable codes, standards and regulations.
The operator also must comply with all such codes, standards and
regulations.
• The engine exhaust fumes contain carbon monoxide, which
can be DEADLY. This dangerous gas, if breathed in sufficient
concentrations, can cause unconsciousness or even death.
Do NOT alter or add to the exhaust system or do anything that
might render the system unsafe or in noncompliance with
applicable codes and standards.
• Install a battery operated carbon monoxide alarm indoors,
according to manufacturer's instructions/recommendations.
• Adequate, unobstructed flow of cooling and ventilating air
is critical to correct generator operation. Do not alter the
installation or permit even partial blockage of ventilation
provisions, as this can seriously affect safe operation of the
generator. The generator MUST be installed and operated
outdoors only.
• Keep hands, feet, clothing, etc., away from drive belts, fans,
and other moving or hot parts. Never remove any drive belt or
fan guard while the unit is operating.
• When working on this equipment, remain alert at all times.
Never work on the equipment when physically or mentally
fatigued.
• Inspect the generator regularly, and contact the nearest Dealer
for parts needing repair or replacement.
• Before performing any maintenance on the generator,
disconnect its battery cables to prevent accidental start up.
Disconnect the cable from the battery post indicated by a
NEGATIVE, NEG or (–) first, then remove the POSITIVE, POS
or (+) cable. When reconnecting the cables, connect the
POSITIVE cable first, the NEGATIVE cable last.
• Never use the generator or any of its parts as a step. Stepping
on the unit can stress and break parts, and may result in
dangerous operating conditions from leaking exhaust gases,
fuel leakage, oil leakage, etc.

ELECTRICAL HAZARDS
• All generators covered by this manual produce dangerous
electrical voltages and can cause fatal electrical shock. Utility
power delivers extremely high and dangerous voltages to
the transfer switch as does the standby generator when it
is in operation. Avoid contact with bare wires, terminals,
connections, etc., while the unit is running. Ensure all
appropriate covers, guards and barriers are in place, secured
and/or locked before operating the generator. If work must
be done around an operating unit, stand on an insulated, dry
surface to reduce shock hazard.
• Do not handle any kind of electrical device while standing
in water, while barefoot, or while hands or feet are wet.
DANGEROUS ELECTRICAL SHOCK MAY RESULT.
• The National Electrical Code (NEC) requires the frame and external
electrically conductive parts of the generator to be connected to
an approved earth ground. Local electrical codes also may require
proper grounding of the generator electrical system.
2
• After installing this home standby electrical system, the generator

may crank and start at any time without warning. When this
occurs, load circuits are transferred to the STANDBY (generator)
power source. To prevent possible injury if such a start and
transfer occur, always set the generator's AUTO/OFF/MANUAL
switch to its OFF position before working on equipment and
remove the 15A fuse from the generator control panel.
• In case of accident caused by electric shock, immediately shut
down the source of electrical power. If this is not possible, attempt
to free the victim from the live conductor. AVOID DIRECT CONTACT
WITH THE VICTIM. Use a nonconducting implement, such as a
dry rope or board, to free the victim from the live conductor. If the
victim is unconscious, apply first aid and get immediate medical
help.
• Never wear jewelry when working on this equipment. Jewelry
can conduct electricity resulting in electric shock, or may get
caught in moving components causing injury.
• For fire safety, the generator must be installed and maintained
properly. Installation must always comply with applicable
codes, standards, laws and regulations. Adhere strictly to local,
state and national electrical and building codes. Comply with
regulations the Occupational Safety and Health Administration
(OSHA) has established. Also, ensure that the generator is
installed in accordance with the manufacturer's instructions
and recommendations. Following proper installation, do
nothing that might alter a safe installation and render the unit in
noncompliance with the aforementioned codes, standards, laws
and regulations.
• Keep a fire extinguisher near the generator at all times.
Extinguishers rated "ABC" by the National Fire Protection
Association are appropriate for use on the standby electric
system. Keep the extinguisher properly charged and be familiar
with its use. Consult the local fire department with any questions
pertaining to fire extinguishers.
• Do not smoke around the generator. Wipe up any fuel or oil spills
immediately. Ensure that no combustible materials are left in the
generator compartment, or on or near the generator, as FIRE or
EXPLOSION may result. Keep the area surrounding the generator

clean and free from debris.
• Gaseous fluids such as natural gas and liquid propane (LP)
gas are extremely EXPLOSIVE. Install the fuel supply system
according to applicable fuel-gas codes. Before placing the home
standby electric system into service, fuel system lines must be
properly purged and leak tested according to applicable code.
After installation, inspect the fuel system periodically for leaks.
No leakage is permitted.
• Generator engine exhaust contains DEADLY carbon monoxide, an
odorless, colorless poisonous gas. Breathing carbon monoxide
can cause: dizziness, throbbing temples, nausea, muscular
twitching, headache, vomiting, weakness and sleepiness,
inability to think clearly, fainting, unconsciousness or even death.
If you experience any carbon monoxide poisoning symptoms,
move into fresh air and immediately seek medical attention.
• Never operate the generator set with the vehicle inside any
garage or other enclosed area.

FIRE HAZARDS

EXPLOSION HAZARDS

ENGINE EXHAUST HAZARDS


