Table of Contents
Advertisement
QB-3/9 OWNER'S MANUAL
PROOFER:
Fig. #4 – Manual Fill Proofer Controls
For the Standard Manual Fill Proofer - -
Begin to pre-heat the Proofer section of the QB-3/9 about 20 to 30 minutes before its scheduled use.
A. Set out the desired product for thawing. Be sure to allow sufficient time in your schedule
for both the product and your equipment to reach the correct conditions.
B.
Prepare the Proofer:
1.
Set the Proofer Power Switch [31] to ON.
2.
Set the Proofer Temperature Control [32] to the required. Begin preheating the Proofer at
least 20 minutes prior to its scheduled use.
3.
Set the Proofer Humidity Control [34] to the required. Manual fill units require time to heat
the water and raise the internal humidity level; these units must be started at least 20
minutes before use.
4.
Make sure the Water Pan [64] contains no less than 1" of water. The water level should be
checked every time you load the Proofer, and at least every other hour during operations.
Use warm water whenever you refill the pan.
5.
The Proofer is ready for use when the Temperature and Humidity Indicator Lights go out
and a light to moderate fogging appears on the Proofer Door [42].
IMPORTANT: ALWAYS REDUCE THE HUMIDITY SETTING TO A MINIMAL LEVEL WHEN
OPERATING THE PROOFER FOR EXTENDED PERIODS WITHOUT ANY PRODUCT
C. Load the product. The pans should be pushed all the way back and centered from side to side as
much as possible on each Proofer Shelf to allow for proper air circulation over and around your
product. If you are loading a single pan, center it on the Shelf from side to side and front to back.
NOTE: The Indicator Lights will turn on and off as the Temperature and Humidity Controls
regulate the conditions in the Proofer. This is normal and may happen several times during a
proofing cycle.
®
NU-VU
FOOD SERVICE SYSTEMS
(800) 338-9886
OPERATING INSTRUCTIONS
INSIDE!
Sales Fax (906) 863-5889 ♦ Service Fax (906) 863-6322
MAINTENANCE AND CLEANING GUIDE
MENOMINEE MICHIGAN 49858-0035
9
page
Advertisement
Table of Contents
