Related Manuals for AmeriWater GRUNDFOS CHI
Summary of Contents for AmeriWater GRUNDFOS CHI
- Page 1 DISTRIBUTION PUMP SYSTEM OPERATION & MAINTENANCE MANUAL GRUNDFOS CHI PUMPS Manufactured With Pride In The USA www.ameriwater.com • 800-535-5585 AmeriWater • 3345 Stop 8 Rd. • Dayton, OH 45414 P/N 98-0115 Rev. A...
- Page 2 P/N 98-0115 Rev. A...
-
Page 3: Table Of Contents
TABLE OF CONTENTS THEORY OF OPERATION…………………………………….….…1 INSTALLATION…………………………………………………….….2 START-UP……..…………………………………..………………..….2 PUMP GENERAL DATA……………………………………………..4 PUMP CURVES……...……………………………………………..…5 PUMP TECHNICAL DATA…………………………………………..6 PUMP CONNECTIONS……………………………………………….8 ADJUSTING THE TIMER (DUAL PUMPS ONLY)………….10 SPARE PARTS LISTING………………………………………..…11 DRAWINGS………………………………………………… ……..12 … P/N 98-0115 Rev. A... -
Page 4: Theory Of Operation
DISTRIBUTION PUMP THEORY OF OPERATION The AmeriWater distribution pump takes the water from the storage tank, pumps it through the distribution loop to the points of use for dialysis and re-circulates water back through the piping to the storage tank. This provides pressurized water to each dialysis wall box in addition to re-circulating the water. -
Page 5: Installation
5. Locate the pump control on a wall as close to the pump system as possible. When installing a distribution pump along with an AmeriWater Central Water System, refer to the Plumbing and Instrumentation Diagram (P&ID) for the best location and where connections are made. - Page 6 3. Once the power source has been connected, check the rotation of the pump. Turn the disconnect to the ON position. Jog each pump by momentarily turning the pump power switch to the HAND position. A second person may be needed to see which way the motor armature is turning just before it coasts to a stop.
-
Page 7: Pump General Data
GRUNDFOS Pump P/N 98-0115... -
Page 8: Pump Curves
P/N 98-0115... -
Page 9: Pump Technical Data
P/N 98-0115... - Page 10 P/N 98-0115...
-
Page 11: Pump Connections
Pump Connections P/N 98-0115... - Page 12 Pump Connections P/N 98-0115...
-
Page 13: Adjusting The Timer (Dual Pumps Only)
Adjusting the Timer With the power off and the system properly locked out, open the control panel. In the middle of the box, you will see the OMRON timer as shown below. To adjust the timer, simply insert a small screwdriver into the screw lower right hand face of the timer. -
Page 14: Spare Parts Listing
Spare Parts List Part # Description 80-0128 Pump, 3/4HP, Single Phase,115/230V 80-0129 Pump, 1HP, Three Phase, 208-230/460V 80-0134 Pump, 3/4HP, Three Phase, 208-230/460V 80-0135 Pump, 1HP, Single Phase,115/230V 041-0033 Check Valve, Ball Spring Loaded 43530710 Stainless Steel Pressure Gauge 0-100psi 61670245 Contactor, AB, 9 AMP, 3 Pole, 120V Coil 61760226... -
Page 15: Drawings
Single Distribution Single Phase Controller P/N 98-0115... - Page 16 Single Distribution 115 & 220V Single Phase Controller Schematic P/N 98-0115...
- Page 17 Single Distribution Three Phase Controller P/N 98-0115...
- Page 18 Single Distribution 208V & 230V Three Phase Controller Schematic P/N 98-0115...
- Page 19 Single Distribution 460V Three Phase Controller Schematic P/N 98-0115...
- Page 20 Dual Distribution Single Phase Controller P/N 98-0115...
- Page 21 Dual Distribution 220V Single Phase Controller Schematic P/N 98-0115...
- Page 22 Dual Distribution Three Phase Controller P/N 98-0115...
- Page 23 Dual Distribution 208V Three Phase Controller Schematic P/N 98-0115...
- Page 24 Dual Distribution 230 Volt Three Phase Controller Schematic P/N 98-0115...
- Page 25 Dual Distribution 460 Volt Three Phase Controller Schematic P/N 98-0115...
- Page 26 Single Distribution Pump Assembly P/N 98-0115...
- Page 27 Dual Distribution Pump Assembly P/N 98-0115...
- Page 28 (PVC). The AmeriWater system you have purchased may contain PVC or stainless steel parts. While warnings are only required in the State of California, AmeriWater has initiated the use of Prop 65 labeling for all products to ensure compliance with California regulations. Please note that the above warning does not necessarily mean that the product that you have purchased is unsafe.
Need help?
Do you have a question about the GRUNDFOS CHI and is the answer not in the manual?
Questions and answers