Page 1
Commercial Cyclonic Dust Collector Owners Manual Oneida Air Systems, Inc. 1001 West Fayette St., Syracuse, N.Y. 13204 Phone 1-800-732-4065 315-476-5151 Fax 315-476-5044 www.oneida-air.com...
Page 2
Thank You for Choosing an Oneida Air Systems Product! Read the entire Owners Manual before installing or operating system! Proudly Made in the U.S.A. Table of Contents Page Read Before Installing System 2HP Commercial Wood Dust Collector Owners Manual O.A.S. 2002...
Check amperage draw during operation with all blast gates open. Make certain amperage is not outside operating limit indicated on motor plate! Warning If amperage is too high - shut down immediately! (See troubleshooting section.) 2HP Commercial Wood Dust Collector Owners Manual O.A.S. 2002...
Page 4
1. No Filter - Vent Outside - Caution: 2. External Cartridge Filter - 1. No Filter Do NOT remove fabric straps from filter. 3. External Tube Filters - 2. External Cartridge Filter 3. External Tube Filter 2HP Commercial Wood Dust Collector Owners Manual O.A.S. 2002...
Page 5
III. General Specifications & Fan Performance Curves 2hp Fan Performance Curve 2hp Commercial System 2HP Commercial Wood Dust Collector Owners Manual O.A.S. 2002...
Page 6
2hp Outlet Detail For Minimum Mounting Heights Always check the External Tube Filter actual system height to determine your mounting height. Note: Check drum height, it will affect your bracket height. Top View 2HP Commercial Wood Dust Collector Owners Manual O.A.S. 2002...
Page 7
Plenum can go to the right or left of the cyclone. Many configurations are possible. External Filter Plenum Outlet can be rotated and oriented independent of inlet. 2hp Cyclone with Fan 2HP Cyclonic Wood Dust Collector Owners Manual O.A.S. 2002...
VI. General Assembly Note: For cyclonic preseparation there must be an air tight seal between cyclone and dust container. Dust bin must be located vertically under cyclone, material drops down by gravity. 2HP Commercial Wood Dust Collector Owners Manual O.A.S. 2002...
Note: When installing the brackets on a concrete wall, mount 2 x 4s between wall and brackets to stabilize and dampen vibration. Note: Please do not install an Oneida Dust Collection System alone. Competent assistence is advisable. Units are heavy! 2HP Commercial Wood Dust Collector Owners Manual O.A.S. 2002...
Page 10
See Fig. 3 IMPORTANT: Stay clear of fan exhaust while collector is operating. For External Cartridge, Tube Filter or No Filter models See Filter Assembly Section, pages 10 & 11 for details. 2HP Commercial Wood Dust Collector Owners Manual O.A.S. 2002...
Option - No Filter Assembly Note: Do not return exhaust air to the shop unless filter media is added. Caution: External Filter Assembly Do not remove bands. External Filter Cartridge Cleaning Intervals 2HP Commercial Wood Dust Collector Owners Manual O.A.S. 2002...
Page 12
X. External Filter Bag Assembly Build your own plenum Note: The number of filters and hole configurations vary. Check with a sales technician if you have questions. O.A.S. 2002 2HP Commercial Wood Dust Collector Owners Manual...
Page 13
XI. Fan Outlet Transition, Silencer and Angle Iron Stand 2HP Commercial Wood Dust Collector Owners Manual O.A.S. 2002...
Page 14
XII. Fan / Blower Wiring Diagram Wiring should always be done by a licensed electrician! Before Operation Electrical Wiring 2hp Fan / Blower Wire Diagram - Single & Three Phase Single Phase Three Phase Single Phase Three Phase Low Voltage...
Before Operation: Do not operate Fan / Blower unless Cyclone and Dust Bin are in place! Motor will overheat! Electrical Wiring: Lubrication: Caution: Rotating Fan Blades! Keep objects clear of outlet. 2HP Cyclonic Wood Dust Collector Owners Manual O.A.S. 2002...
Page 16
XIV. Options Exhaust Diverter Square-to-Round Flex Hose Splitter Kit Fiber or Steel Dust Bins Our stock drums range from 34 to 35 3/4. Remote Control Switch - Stand - 2hp 2HP Commercial Wood Dust Collector Owners Manual O.A.S. 2002...
Poor Dust Pick-Up at Woodworking Machines Improper motor rotation - Running backwards will reduce suction by 30%. Filter Clogging Note: If you continue to experience difficulty with your collector call Oneida Air Systems at 1-800-732-4065 for assistance. 2HP Cyclonic Wood Dust Collector Owners Manual...
Page 18
Do not use this product to collect other types of dust or flammable vapors. Fire or explosion may occur! 2HP Cyclonic Wood Dust Collector Owners Manual O.A.S. 2002...
XVII. Terms and Conditions Checking in Order Limited Warranty Delivery Risk of Loss Returned Goods Policy There will be a 25% restocking fee applied to any returned items. 2HP Commercial Wood Dust Collector Owners Manual O.A.S. 2002...